Pumping performance for double-stage lobe mixer/ejector
-
摘要: 采用实验和数值方法对双级波瓣引射混合器的引射性能进行研究,重点研究混合管在两种不同进口方式下的引射混合器气动特征差异,并初步分析混合管面积比和长径比对双级波瓣引射混合器引射性能的影响.结果表明:混合管进口方式对引射能力有非常重要的影响,在研究的结构参数条件下,对于受限式进口,单级波瓣引射混合器的引射能力要强于双级波瓣引射混合器约10%;而对于敞开式进口,其引射能力要优于受限式进口最大约35%,此时双级波瓣引射混合器的引射能力要略好于单级波瓣引射混合器.在较大的混合管面积比或较小的长径比下,敞开式进口下双级波瓣引射混合器较受限式进口表现尤为优越.Abstract: The pumping performances of double-stage lobe mixer/ejector were experimentally and numerically investigated. The aerodynamic characteristics difference of mixer/ejector between two inlet modes of mixing duct was illustrated and the effects of mixing duct area ratio and length-diameter ratio on the pumping performance of double-stage lobe mixer/ejector were preliminarily analyzed. The results show that the inlet mode of mixing duct has strong influence on pumping capacity. Under the present configuration parameters, the pumping capacity of single-stage lobe mixer/ejector is 10% superior to that of double-stage lobe mixer/ejector in the case of confined inlet. While in the case of open inlet, the pumping capacity is 35% superior to that of confined inlet at most. The pumping capacity of double-stage lobe mixer/ejector is stronger than that of single-stage lobe mixer/ejector. Especially for the mixing duct with bigger area ratio or less length-diameter ratio, the pumping performances of double-stage lobe mixer/ejector in the case of open inlet is superior to that of confined inlet.
-
Key words:
- mixer/ejector /
- double-stage lobed nozzle /
- pumping performance /
- experimental test /
- inlet mode
-
[1] Francois T.Internal aerodynamics of infrared suppressors for helicopter engines[J].Journal of the American Helicopter Society,1988,33(4):4-14. [2] Power G D,McClure M D,Vinh D.Advanced IR suppressor design using a combined CFD/test approach[R].AIAA 94-3215,1994. [3] Ponton T,Warnes G.Helicopter IRS engine integeration for the 'first' technology demonstrator programme[R].ASME Paper GT2007-27408,2007. [4] Presz W M,Morin B L,Gousy R G.Forced mixer lobes in ejector designs[J].Journal of Propulsion and Power,1988,4(4):350-355. [5] Skebe S,McCormick D,Presz W.Parameter effects on mixer-ejector pumping performance[R].AIAA 88-7018,1988. [6] 张靖周,李立国,高潮,等.波瓣喷管红外抑制系统的实验研究[J].航空动力学报,1997,12(2):212-214. ZHANG Jingzhou,LI Liguo,GAO Chao,et al.An experimental study on a lobed nozzle of an infrared suppression system[J].Journal of Aerospace Power,1997,12(2):212-214.(in Chinese) [7] Liu Y H.Experimental and numerical investigation of circularly lobed nozzle with/without central plug[J].International Journal of Heat and Mass Transfer,2002,45(12):2577-2585. [8] Zhang J Z,Shan Y,Li L G.Computation and validation of parameter effects on lobed mixer-ejector performances[J].Chinese Journal of Aeronautics,2005,18(3):193-198. [9] 张靖周,单勇,李立国.直升机排气系统用波瓣喷管引射混合式红外抑制器研究[J].航空学报,2007,28(1):32-36. ZHANG Jingzhou,SHAN Yong,LI Liguo.Investigation on lobed nozzle mixer-ejector infrared suppressor for helicopter exhaust system[J].Acta Aeronautica et Astronautica Sinica,2007,28(1):33-36.(in Chinese) [10] SHAN Yong,ZHANG Jingzhou.Numerical investigation of flow mixture enhancement and infrared radiation shield by lobed forced mixer[J].Applied Thermal Engineering,2009,29(17/18):3687-3695. [11] 刘友宏,郭楠,李江宁,等.后缘切角对波瓣混合器性能影响[J].航空动力学报,2009,24(9):1917-1922. LIU Youhong,GUO Nan,LI Jiangning,et al.Effect of cut angles at trailing edge on the performance of a lobed mixer[J].Journal of Aerospace Power,2009,24(9):1917-1922.(in Chinese) [12] 王先炜,黄勇,路玉霞.旋翼下洗气流对红外抑制器性能的影响研究[J].航空动力学报,2003,18(6):772-776. WANG Xianwei,HUANG Yong,LU Yuxia.Influences of the downwash flow from a helicopter rotor on the performances of an infrared suppressor[J].Journal of Aerospace Power,2003,18(6):772-776.(in Chinese) [13] 唐正府,张靖周,单勇.波瓣喷管-狭长出口弯曲混合管引 射混合特性研究[J].航空动力学报,2005,20(6):978-982. TANG Zhengfu,ZHANG Jingzhou,SHAN Yong.Investigation on ejecting and mixing characteristics of lobed nozzle with curved mixing duct and slot exit[J].Journal of Aerospace Power,2005,20(6):978-982.(in Chinese) [14] 唐正府,张靖周,王先炜,等.排气系统与尾机身一体化红外抑制器实验分析[J].航空动力学报,2007,22(2):233-237. TANG Zhengfu,ZHANG Jingzhou,WANG Xianwei,et al.Experimental research on infrared suppressor integrating the exhaust system with the tail part of a helicopter[J].Journal of Aerospace Power,2007,22(2):233-237.(in Chinese) [15] Bettini C,Cravero C,Cogliandro S.Multidisciplinary analysis of a complete infrared suppression system[R].ASME Paper GT2007-27721,2007. [16] 王同辉,王先炜,张靖周,等.直升机红外抑制器遮挡罩间距对红外辐射特性的影响[J].航空动力学报,2009,24(7):1493-1499. WANG Tonghui,WANG Xianwei,ZHANG Jingzhou,et al.Effect of covering shelter on infrared radiation characteristics of helicopter infrared radiation suppressor[J].Journal of Aerospace Power,2009,24(7):1493-1499.(in Chinese) [17] 潘丞雄,张靖周,单勇,等.引射/强迫式波瓣混合器开设通气狭缝的流动分离控制[J].航空动力学报,2013,28(2):331-337. PAN Chengxiong,ZHANG Jingzhou,SHAN Yong,et al.Flow separation control of lobed ejector/forced mixer by ventilation[J].Journal of Aerospace Power,2013,28(2):331-337.(in Chinese) [18] Presz W M,Werle M.Multi-stage mixer/ejector system[R].AIAA-2002-4064,2002. [19] 鲁盼,黄勇,王方,等.面积比、波瓣张角对多级波瓣喷管性能的影响研究[J].航空发动机,2010,36(6):12-17. LU Pan,HUANG Yong,WANG Fang,et al.Area ration and lobe angle influence on the performance of multistage lobed nozzles[J].Aeroengine,2010,36(6):12-17.(in Chinese)
点击查看大图
计量
- 文章访问数: 1528
- HTML浏览量: 3
- PDF量: 888
- 被引次数: 0