小展弦比带掠风扇转子叶片的耦合颤振

吴长波; 周拜豪; 崔海涛; 高源

doi:10.13224/j.cnki.jasp.2014.12.014

小展弦比带掠风扇转子叶片的耦合颤振

doi: 10.13224/j.cnki.jasp.2014.12.014

1. 南京航空航天大学能源与动力学院, 南京 210016;
2. 中国航空工业集团公司中国燃气涡轮研究院 18室, 成都 610500

详细信息

作者简介:
吴长波(1974-), 男, 山东烟台人, 研究员, 博士生, 主要从事发动机强度及材料应用研究.

中图分类号: V231.3
计量
- 文章访问数: 1302
- HTML浏览量: 3
- PDF量: 995
- 被引次数: 0
出版历程
- 收稿日期: 2013-07-30
- 刊出日期: 2014-12-28

Coupling flutter of swept fan rotor blade with small aspect ratio

1. College of Energy and Power Engineering, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;
2. 18 Research Office, China Gas Turbine Establishment, Aviation Industry Corporation of China, Chengdu 610500, China

摘要

摘要: 从结构力学出发,对某发动机整体叶盘进行了盘片耦合振动特性分析,通过分析小展弦比带掠风扇转子叶片的共振转速、耦合颤振和失速颤振,发现了该小展弦比带掠风扇转子叶片存在2阶与3阶动频与静频振型发生变化的特殊现象,揭示了该小展弦比带掠风扇转子叶片为另一种耦合颤振的问题.通过对该小展弦比带掠风扇转子叶片的结构调整,找出了叶片前掠是该叶片发生此类特殊现象的重要影响因素,适当压缩该叶片的前掠后,从设计上避免了发生颤振的可能,提出叶片各阶频率的分离度需满足10％的设计要求.
- 整体叶盘 /
- 小展弦比 /
- 前掠 /
- 失速颤振 /
- 耦合颤振
Abstract: Based on structural mechanics, blade coupling flutter characteristics of an engine blisk were analyzed.Analyses of resonance rotating speed, coupling flutter and stall flutter were accomplished by swept fan rotor blade with small aspect ratio. The unusual phenomena showing that the change of dynamic and static frequencies of second-order and third-order on the swept fan blade with small aspect ratio were found, and recognized as another problem relating to coupling flutter. By structure adjustment of swept fan rotor blade with small aspect ratio, it was found that swept-forward blade was an important factor to this unusual phenomenon. Reducing the swept degree of the blade appropriately can avoid the possibility of flutter by design.It is suggested the separation of order frequency degree for the blade should satisfy the design requirement of 10%.
- blisk /
- small aspect ratio /
- swept-forward /
- stall flutter /
- coupling flutter

HTML

参考文献(18)

[1]	张明明,李绍斌,侯安平,等.叶轮机械叶片颤振研究的进展与评述[J].力学进展,2011,41(1):26-38. ZHANG Mingming,LI Shaobin,HOU Anping,et al.A review of the research on blade flutter in turbomachinery[J].Advances in Mechanics,2011,41(1):26-38.(in Chinese)
[2]	王营,陶智,杜发荣,等.小展弦比空心风扇叶片流固耦合作用下的叶片响应分析[J].航空动力学报,2008,23(12):2177-2183. WANG Ying,TAO Zhi,DU Farong,et al.Response analysis of fluid and solid coupling characteristics for a wide-chord hollow fan blade[J].Journal of Aerospace Power,2008,23(12):2177-2183.(in Chinese)
[3]	张小伟,王延荣.叶间相位角对叶片颤振的影响[J].航空动力学报,2010,25(2):412-416. ZHANG Xiaowei,WANG Yanrong.Influence of interblade phase angle on the flutter of rotor blades[J].Journal of Aerospace Power,2010,25(2):412-416.(in Chinese)
[4]	陶春虎,钟培道,王仁智,等.航空发动机转动部件的失效与预防[M].北京:国防工业出版社,2000.
[5]	朱俊强,刘前智.航空叶片机原理[M].西安:西北工业大学出版社,1996.
[6]	Carta F O.Coupled blade-disc-shroud flutter instabilities in turbojet engine rotors[R].ASME Paper 66-WA/GT-6,1966.
[7]	周盛.叶轮机气动弹性力学引论[M].北京:国防工业出版社,1986.
[8]	航空发动机设计手册总编委会.航空发动机设计手册:第18册叶片轮盘及主轴强度分析[M].北京:航空工业出版社,2001.
[9]	饶寿期.航空涡喷涡扇发动机结构设计准则研究报告:第3册叶片[R].北京:中国航空工业总公司发动机系统工程局,1997.
[10]	Steffens K.Advanced compressor technology:key success factor for competitiveness in modern aero engines[R].ISABE-2001-1009,2001.
[11]	Wadia A R,Hah C,Rabe D.The impact of forward sweep on tip clearance flows in transonic compressors[R].ICAS 2004-6.2.1,2004.
[12]	Thomson D,Watson K,Gorrell S.Assessment of organic matrix composites for a forward swept fan stage[R].AIAA 94-1353-CP,1994.
[13]	Wadia A R,Szucs P N,Crall D W.Inner workings of aerodynamic sweep[J].Journal of Turbomachinery,1998,120(4):671-682.
[14]	桂幸民,周拜豪.压缩系统跨声进口级弯掠叶片空气动力学概述[J].航空动力学报,1995,10(4):407-411. GUI Xingmin,ZHOU Baihao.A summary of lean-sweep aerodynamics in transonia inlet stages for compression system[J].Journal of Aerospace Power,1995,10(4):407-411.(in Chinese)
[15]	邢秀清,单鹏,周盛.风扇转子前缘曲线相对掠对性能的影响[J].航空动力学报,2000,15(1):39-43. XING Xiuqing,SHAN Peng,ZHOU Sheng.Effects of swept leading edge on performance of fans[J].Journal of Aerospace Power,2000,15(1):39-43.(in Chinese)
[16]	吴长波,崔海涛,徐拓,等.某风机叶片的弯扭耦合颤振问题分析与验证[J].航空动力学报,2012,27(3):623-627. WU Changbo,CUI Haitao,XU Tuo,et al.Analysis and experiment on coupled flutter of a wide-chord blade[J].Journal of Aerospace Power,2012,27(3):623-627.(in Chinese)
[17]	徐峰,李春松,罗秋生,等.轴流压气机整体叶盘叶片裂纹故障研究[J].燃气涡轮试验与研究,2012,25(4):25-29. XU Feng,LI Chunsong,LUO Qiusheng,et al.Study on the blade crack of an axial flow compressor blisk[J].Gas Turbine Experiment and Research,2012,25(4):25-29.(in Chinese)
[18]	张大义,史亚杰,林力,等.带宽弦叶片的盘片耦合振动特性研究[J].北京航空航天大学学报,2004,30(9):808-812. ZHANG Dayi,SHI Yajie,LIN Li,et al.Model analysis of bladed disk coupled system of compressor with low aspect ratio[J].Journal of Beijing University of Aeronautics and Astronautics,2004,30(9):808-812.(in Chinese)