三级轴向旋流器燃烧室的贫油熄火性能试验

丁国玉; 安伯堃; 何小民; 赵自强; 金义; 薛冲

doi:10.13224/j.cnki.jasp.2015.02.013

三级轴向旋流器燃烧室的贫油熄火性能试验

doi: 10.13224/j.cnki.jasp.2015.02.013

1. 南京航空航天大学能源与动力学院江苏省航空动力系统重点实验室, 南京 210016;
2. 哈尔滨东安发动机(集团)有限公司, 哈尔滨 150066

基金项目:

江苏省普通高校研究生科研创新计划(CXLX12_0169)

南京航空航天大学博士学位论文创新与创优基金(BCXJ14-01)

详细信息

作者简介:
丁国玉(1985-),男,山东潍坊人,博士生,主要从事航空发动机燃烧室和燃烧理论的研究.

中图分类号: V231.3
计量
- 文章访问数: 1435
- HTML浏览量: 3
- PDF量: 833
- 被引次数: 0
出版历程
- 收稿日期: 2013-09-04
- 刊出日期: 2015-02-28

Experiment on lean blowout performance of triple axial swirler combustor

1. Jiangsu Province Key Laboratory of Aerospace Power System, College of Energy and Power Engineering, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;
2. Harbin Dongan Engine (Group) Corporation Limited, Harbin 150066, China

摘要

摘要: 对三级轴向旋流器燃烧室进行了不同进口速度、进口温度、三级轴向旋流器旋向组合和空气流量分配下的贫油熄火性能试验.研究结果表明:随着进口速度、进口温度的增加,三级轴向旋流器燃烧室的贫油熄火油气比减小,进口温度的升高对贫油熄火性能的影响显著;相同进口速度下旋向组合为逆时针-逆时针-顺时针方案的贫油熄火油气比比旋向组合为顺时针-逆时针-顺时针方案的贫油熄火油气比约高50%;内旋流器空气流量的减小可使得贫油熄火油气比有所减小,但减小的幅度不大.
- 三级轴向旋流器 /
- 燃烧室 /
- 贫油熄火 /
- 油气比 /
- 燃烧室性能
Abstract: Experiments were conducted to study the lean blowout (LBO) performance of triple axial swirler combustor at different inlet airflow velocities, inlet airflow temperatures, triple axial swirler rotational direction combinations and airflow mass flow rate distributions. The results show that: the lean blowout fuel-air ratio (LBO FAR) of triple axial swirler combustor decreases with increasing inlet airflow velocity and inlet airflow temperature, and inlet airflow temperature has great effect on LBO performance; the LBO performance of scheme with rotational direction combination of counterclockwise-counterclockwise-clockwise is improved by about 50% compared with that of clockwise-counterclockwise-clockwise at the same inlet airflow velocity; the LBO FAR decreases to a little extent when the inner swirler airflow mass flow rate decreases.
- triple axial swirler /
- combustor /
- lean blowout /
- fuel-air ratio /
- combustor performance

HTML

参考文献(16)

[1]	林宇震,许全宏,刘高恩.燃气轮机燃烧室[M].北京:国防工业出版社,2008.
[2]	Bahr D W.Technology for the design of high temperature rise combustors[R].AIAA 85-1292,1985.
[3]	Mongia H C.Engineering aspects of complex gas turbine combustion mixers:Part Ⅰ high △T[R].AIAA-2011-107,2011.
[4]	LI Guoqiang,Gutmark E J.Flow field measurement of triple swirler spray combustor[R].AIAA-2002-4010,2002.
[5]	LI Guoqiang,Gutmark E J.Combustion characteristics of a multiple swirl spray combustor[R].AIAA-2003-0489,2003.
[6]	Zheng Q P,Jasuja A K,Lefebvre A H.Structure of air blast sprays under high ambient pressure conditions[J].Journal of Engineering for Gas Turbines and Power,1997,119(3):512-518.
[7]	Jasuja A K,Tam C K.Determination of air blast atomized spray structure using state-of-the-art laser diagnostics[R].AIAA 92-3232,1992.
[8]	袁怡祥,林宇震,刘高恩.旋流杯燃烧室头部流场与喷雾对贫油熄火的影响[J].航空动力学报,2004,19(3):332-336. YUAN Yixiang,LIN Yuzhen,LIU Gaoen.The effect of flow field and fuel spray of combustor with swirl cup on lean blowout limit at idle condition[J].Journal of Aerospace Power,2004,19(3):332-336.(in Chinese)
[9]	袁怡祥,林宇震,刘高恩.三旋流器头部燃烧室拓宽燃烧稳定工作范围的研究[J].航空动力学报,2004,19(1):142-147. YUAN Yixiang,LIN Yuzhen,LIU Gaoen.Combustor dome design with three swirlers for widening the operation stability range[J].Journal of Aerospace Power,2004,19(1):142-147.(in Chinese)
[10]	LI Guoqiang,Gutmark E J.Experimental and numerical studies of the velocity field of a triple annular swirler[R].ASME Paper GT-2002-30069,2002.
[11]	LI Guoqiang,Angier S,Lambolez O,et al.Experimental study of velocity flow field for a multiple wwirl spray combustor[R].AIAA-2002-0618,2002.
[12]	吴治永,林宇震,刘高恩,等.基于CFD分析改进三旋流燃烧室头部设计[J].推进技术,2009,30(5):533-537. WU Zhiyong,LIN Yuzhen,LIU Gaoen,et al.Dome structure modification of a high temperature rise combustor based on CFD simulation[J].Journal of Propulsion Technology,2009,30(5):533-537.(in Chinese)
[13]	刘伟,林宇震,刘高恩,等.低压条件下复合式多级旋流杯燃烧室燃烧效率研究[J].航空动力学报,2004,19(5):650-655. LIU Wei,LIN Yuzhen,LIU Gaoen,et al.Research of combustion efficiency of combustors using hybrid airblast atomizer under low pressure[J].Journal of Aerospace Power,2004,19(5):650-655.(in Chinese)
[14]	宁榥,高歌.燃烧室气动力学[M].北京:科学出版社,1987.
[15]	航空发动机设计手册总编委会.航空发动机设计手册:第9分册[M].北京:航空工业出版社,2000.
[16]	Mohammad B S,Jeng S M.Design procedures and a developed computer code for preliminary single annular combustor design[R].AIAA-2009-5208,2009.