Micro bubble nucleation inside suspended droplet in combustion
-
摘要: 利用高速显微摄像技术观测了航空煤油RP-3的微尺度挂滴燃烧过程,分析了油滴内微气泡成核的基本机理和表现形式.在凸曲率诱发的低压成核机理下,确证了3种具体成核形式:①挂丝/油滴界面成核.挂丝温度高于油滴温度,在交界面上由于温差诱导了蒸发效应形成微气泡成核.②颗粒/油滴界面成核.微油滴内的微米量级的丝状或球状杂质颗粒及胶质颗粒形成的凸曲率侧诱导低压,成为气泡的萌生的成核点.③油滴表面凹坑成核.重组分形成筏结构与油滴表面侧的线张力和表面张力同时作用,引起油滴表面内凹,凹坑的凸曲率侧气泡成核点.这些进展为深入研究微尺度燃烧奠定了基础.Abstract: High-speed microscopic camera technology was utilized to observe and research the micro-scale suspend droplet combustion process of aviation kerosene RP-3. The basic mechanism of micro bubble nucleation inside droplet and manifestation were analyzed. Under convex curvature induced nucleation mechanism at low pressure, three forms of nucleation which were confirms were including:(1) Nucleation in the interface of the suspended silk/droplet. The temperature of suspended silk was higher than the droplet temperature on interface, and temperature difference induced the evaporation effect to form the micro bubbles nucleation.(2) Nucleation in the interface of the particles/droplet. Several micrometer range filiform or globular impurity particles or colloid particles inside droplet that form convex curvature side to induce meiobar, in which burgeon bubbles nucleation points.(3) Nucleation on pits of droplet surface. Heavy components form the raft structure and the line tension and surface tension of the droplet surface side simultaneous effect cause indent of the droplet surface, which sprout bubbles nucleation points in the convex curvature side of the pit.These developments laid the foundation for further research on micro-scale combustion.
-
Key words:
- suspended droplet /
- combustion /
- micro bubble /
- nucleation mechanism /
- nucleation form
-
[1] Wang C H,Liu X Q,Law C K.Combustion and microex-plosion of freely falling multicomponent droplet[J].Combustion and Flame,1984,56(2):175-197. [2] 刘卫东,周进,王振国.振荡环境下推进剂油滴亚临界蒸发响应特性[J].航空动力学报,2001,16(1):52-54. LIU Weidong,ZHOU Jin,WANG Zhenguo.Response of propellant droplet subcritical evaporation to environmental pressure oscillation[J].Journal of Aerospace Power,2001,16(1):52-54.(in Chinese) [3] Stengele J,Prommersberger K Willmann M,et al.Experimental and theoretical study of one-and two-component droplet vaporization in a high pressure environment[J].International Journal of Heat and Mass Transfer,1999,42(2):2683-2694. [4] 龚景松,陆奇志,何裕昆,等.煤液化油的蒸发与着火特性[J].燃烧科学与技术,2014,20(1):10-13. GONG Jingsong,LU Qizhi,HE Yukun,et al.Evaporation and ignition characteristics of coal liquefied oil[J].Journal of Combustion Science and Technology,2014,20(1):10-13.(in Chinese) [5] 李辉,龚景松,朴英,等.低功率状态下煤液化油的雾化特性[J].清华大学学报:自然科学版,2014,54(10):1310-1315. LI Hui,GONG Jingsong,PIAO Ying,et al.Atomization characteristics of coal liquefied oil at low power levels[J].Journal of Tsinghua University:Science and Technology,2014,54(10):1310-1315.(in Chinese) [6] Hsieh K C,Shuen J S,Yang V.Droplet vaporization in high-pressure environments:Ⅰ near critical conditions[J].Combustion Science and Technology,1991,76(1/2/3):111-132. [7] Turns S R.An introduction to combustion[M].New York:McGraw-Hill,2000:362-421. [8] ZHOU Ji,MO Jiada,Chow A S,et al.A universal model of droplet vaporization applicable to supercritical conditions[R].AIAA-2000-3850,2000. [9] Khan Q S,Baek S W,Lee S Y.Effect of droplet initial diameter on droplet vaporization regimes for kerosene fuel droplet[R].AIAA-2007-1181,2007. [10] Law C K.Internal boiling and superheating in vaporizing multicomponent droplets[J].AIChE Journal,1978,24(4):626-632. [11] Law C K.Fuel options for next-generation chemical propulsion[J].AIAA Journal,2012,50(1):19-36. [12] Kwak H Y,Oh S D,Park C H.Bubble dynamics on the evolving bubble formed from the droplet at the superheat limit[J].International Journal of Heat and Mass Transfer,1995,38(9):1709-1718. [13] Jeong I,Lee K H,Kim J.Characteristics of auto-ignition and micro-explosion behavior of a single droplet of water-in-fuel[J].Journal of Mechanical Science and Technology,2008,22(1):148-156. [14] 陆奇志,龚景松,朴英,等.挂滴燃烧中的微汽泡行为和油滴跳动[J].航空动力学报,2015,30(6):1344-1349. LU Qizhi,GONG Jingsong,PIAO Ying,et al.Micro bubble behaves inside pendant droplet and droplet oscillations in combustion[J].Journal of Aerospace Power,2015,30(6):1344-1349.(in Chinese) [15] Miglani A,Basu S,Kmar R,et al.Suppression of instabilities in burning droplets using preferential acoustic perturbations[J].Combustion and Flame,2014,161(12):3181-3190. [16] 殷雅俊,吴继业.微纳米空间弯曲诱导的反常驱动力-从泡利的魔鬼谈起[J].力学与实践,2014,36(2):137-146. YIN Yajun,WU Jiye.Abnormal driving forces induced by micro/nano space curvatures-about pauli's devils[J].Mechanics in Engineering,2014,36(2):137-146.(in Chinese) [17] Herring C.Surface tension as a motivation for sintering[M].New York:McGraw-Hill,1951. [18] 田勇.微尺度沸腾核化与汽泡动力特性[D].北京:清华大学,2005. TIAN Yong.Dynamical behavior of microscale boiling nucleation and bubble growth[D].Beijing:Tsinghua University,2005.(in Chinese) [19] 魏可臻,张奇.热电偶热传导测温中的动态响应时间和误差估计[J].测试技术学报,2007,21(6):523-526. WEI Kezhen,ZHANG Qi.Dynamic response time and deviation estimate of thermocouple during heat-exchange temperature measurement[J].Journal of Test and Measurement Technology,2007,21(6):523-526.(in Chinese) [20] Brennen C E.Cavitation and bubble dynamics[M].Cambridge:Cambridge University Press,2013. [21] 刘济赢.中国喷气燃料[M].北京:中国石化出版社,1991. [22] Law C K,Law H K.A d2-law for multicomponent droplet vaporization and combustion[J].AIAA Journal,1982,20(4):522-527. [23] 徐耀祖.相变原理[M].北京:科学出版社,2000. [24] 林瑞泰.沸腾换热[M].北京:科学出版社,1988. [25] LV Cunjing,YIN Yajun,ZHENG Quanshui.Nonlinear effects of line tension in adhesion of small droplets[J]. Applied Mathematics and Mechanics,2008,29(10):1251-1262. [26] Immenschuh S,Baumgart-Vogt E,Tan M,et al.Differential cellular and subcellular localization of heme-binding protein 23/peroxiredoxin I and heme oxygenase:1 in rat liver[J].The Journal of Histochemistry and Cytochemistry,2003,51(12):1621-1631.
点击查看大图
计量
- 文章访问数: 1012
- HTML浏览量: 3
- PDF量: 458
- 被引次数: 0