突加不平衡激励下高速柔性转子系统振动特性试验

洪杰; 陈成; 王永锋; 马艳红

doi:10.13224/j.cnki.jasp.2018.01.002

突加不平衡激励下高速柔性转子系统振动特性试验

doi: 10.13224/j.cnki.jasp.2018.01.002

1.
北京航空航天大学能源与动力工程学院,北京 100191；先进航空发动机协同创新中心,北京 100191
2.
北京航空航天大学能源与动力工程学院,北京 100191

基金项目: 国家自然科学基金（51575022,51475021）

计量
- 文章访问数: 848
- HTML浏览量: 4
- PDF量: 863
- 被引次数: 0
出版历程
- 收稿日期: 2016-06-14
- 刊出日期: 2018-01-28

Vibration test of high speed flexible rotor due to the suddenunbalance

摘要

摘要: 针对航空发动机高速柔性转子系统叶片丢失所造成的突加不平衡激励,基于结构/力学特征等效原则,建立高速柔性悬臂转子系统试验器,对突加不平衡及持续碰摩所产生的附加激励下转子系统振动响应进行试验测试,并对其时域/频域响应特征进行分析。结果表明：突加不平衡瞬时具有显著冲击效应,转子系统瞬态振动响应加剧,并激起转子横向模态振动；转静件之间的持续碰摩会产生约束作用使转子系统临界转速提高,呈现非线性振动,产生谐波振动频率成分。
- 柔性转子 /
- 突加不平衡 /
- 碰摩 /
- 振动试验 /
- 瞬态响应
Abstract: A high speed flexible cantilever rotor test rig was established to investigate the vibration response of the turbofan rotor in time domain and frequency domain under the suddenunbalance and the rubimpact caused by blade loss, based on the equivalence principle of structural/mechanical characteristics. The research showed that, suddenunbalance led to significant impact on rotor, the aggravation of the rotors transient response, and flexural resonance of rotor; the rubimpact between rotor and stator resulted in the increase of the critical speed of rotor and the nonlinear vibration with the super harmonic frequencies.
- flexible rotor /
- suddenunbalance /
- rubimpact /
- vibration test /
- transient response

HTML

参考文献(19)

[1]	COSME N,CHEVROLET D,BONINI J,et al.Prediction of engine loads and damages due to fan blade off event［R］.AIAA2002-1666，2002.
[2]	Federal Aviation Administration.Airworthiness standards aircraft engines:14 CFR Part 33［S］.Washington DC:Federal Aviation Administration,1993:81-99.
[3]	European Aviation Safety Agency.Certification specifications for engines:CSE［S］.Munich,Germany:EASA,2009:140-141.
[4]	SINHA S K.Rotordynamic analysis of asymmetric turbofan rotor due to fan bladeloss event with contactimpact rub loads［J］.Journal of Sound and Vibration,2013,332(9):2253-2283.
[5]	宣海军,陆晓,洪伟荣,等.航空发动机机匣包容性研究综述［J］.航空动力学报,2010,25(8):1860-1870.XUAN Haijun,LU Xiao,HONG Weirong,et al.Review of aeroengine case containment research［J］.Journal of Aerospace Power,2010,25(8):1860-1870.(in Chinese)
[6]	NAIK D,SANKARAN S,MOBASHER B,et al.Development of reliable modeling methodologies for fan blade out containment analysis:Part Ⅰ experimental studies［J］.International Journal of Impact Engineering,2009,36(1):111.
[7]	徐春雨.民用飞机发动机安装节设计载荷要求研究［J］.科技视界,2015(27):135-135.XU Chunyu.Research on design load requirement of civil aircraft engine installation section［J］.Science and Technology Vision,2015(27):135-135.(in Chinese)
[8]	JACQUETRICHARDET G,TORKHANI M,CARTRAUD P,et al.Rotor to stator contacts in turbomachines：review and application［J］.Mechanical Systems and Signal Processing,2013,40(2):401-420.
[9]	GROLL G V,EWINS D J.On the dynamics of windmilling in aeroengines［R］.London:International Conference on Vibrations in Rotating Machinery,2000.
[10]	HIBNER D R,BZLONO D F.Experimental study of transient dynamics of a flexible rotor［R］.NASA CR-2703,1976.
[11]	KALINOWSKI P,BARGEN O,LIEBICH R.Vibrations of rotating machinery due to sudden mass loss［C］∥The Proceedings of 8th IFToMM International Conference on Rotor Dynamics.Seoul,Korea:IFToMM,2010:584-590.
[12]	李其汉,赵福安,张世平.带弹性阻尼支承的转子系统丢失叶片瞬态响应试验研究［J］.航空动力学报,1992,7(2):103-107.LI Qihan,ZHAO Fuan,ZHANG Shiping.Experimental investigation on blade loss transient response of rotor with flexible damped support［J］.Journal of Aerospace Power,1992,7(2):103-107.(in Chinese)
[13]	张力,马艳红,梁智超,等.转子系统碰摩约束模型与振动响应分析［J］.北京航空航天大学学报,2015,41(9):1631-1637.ZHANG Li,MA Yanhong,LIANG Zhichao,et al.Constraint model and vibration response analysis of rotor rubimpact［J］.Journal of Beijing University of Aeronautics and Astronautics,2015,41(9):1631-1637.(in Chinese)
[14]	KIM Y,NOAH S T.Quasiperiodic response and stability analysis for a nonlinear Jeffcott rotor［J］.Journal of Sound and Vibration,1996,190(2):239-253.
[15]	KHANLO H M,GHAYOUR M,ZIAEIRAD S.Chaotic vibration analysis of rotating flexible continuous shaftdisk system with a rubimpact between the disk and the stator［J］.Communications in Nonlinear Science and Numerical Simulation,2011,16(1):566-582.
[16]	JOHN J Y.On occurrence of reverse full annular rub［J］.Journal of Engineering for Gas Turbines and Power,2012,134(1):12505-12512.
[17]	PATEL T H,DARPE A K.Coupled bendingtorsional vibration analysis of rotor with rub and crack［J］.Journal of Sound and Vibration,2009,326(3):740-752.
[18]	高艳蕾,李勇,王德友.转子机匣系统碰摩故障特征试验研究［J］.航空发动机,2002,28(4):16-21.GAO Yanlei,LI Yong,WANG Deyou.Experimental investigation of rotortocasing rubbing fault［J］.Aeroengine,2002,28(4):16-21.(in Chinese)
[19]	梁智超,张振波,刘书国,等.转子支承机匣系统碰摩试验及特征提取［J］.航空动力学报,2014,29(3):604-611.LIANG Zhichao,ZHANG Zhenbo,LIU Shuguo,et al.Experiment and characteristics extraction of rubimpact in rotorsupportcase system［J］.Journal of Aerospace Power,2014,29(3):604-611.(in Chinese)