组分变化对甲烷氧化特性影响

郑玮琳; 庞历瑶; 张世杰; 谢凡; 曾文

doi:10.13224/j.cnki.jasp.2021.01.003

组分变化对甲烷氧化特性影响

doi: 10.13224/j.cnki.jasp.2021.01.003

基金项目: 辽宁省博士科研启动基金(2019-BS-185)

计量
- 文章访问数: 280
- HTML浏览量: 63
- PDF量: 212
- 被引次数: 0
出版历程
- 收稿日期: 2020-05-25
- 刊出日期: 2021-01-28

Effect of composition variance on methane oxidation characteristics

1.
School of Aero-engine,Shenyang Aerospace University,Shenyang 110136,China
2.
Shenyang Aircraft Design and Research Institute,Aviation Industry Corporation of China,Limited,Shenyang 110035,China

摘要

摘要: 在射流搅拌反应器实验平台上针对温度范围850~1 300 K、常压条件下的甲烷氧化反应过程进行了实验研究,采用气相色谱仪测量了变组分条件下(当量比范围02~2、氧气体积分数2%~8%、二氧化碳体积分数0~20%、水蒸气体积分数0~20%)主要反应物(CH4、O2)、主要中间组分(C2H6、C2H4、C2H2、H2)和主要污染物(CO、CO2)的摩尔分数,并分析了主要反应物、中间组分以及污染物生成的影响因素和影响规律。研究表明,随着当量比和含氧量的增加,主要中间组分的摩尔分数升高;二氧化碳体积分数的增加对中间产物的生成有微弱的抑制作用,却使得污染物浓度大大增加;水蒸气体积分数的增加导致氢气生成量显著增加,同时促进一氧化碳的生成,而对二氧化碳的生成影响很小。
- 甲烷 /
- 组分变化 /
- 中间产物 /
- 污染物生成 /
- 射流搅拌反应器
Abstract: The methane oxidation within the temperature range of 850-1 300 K and atmospheric pressure was studied in a jet stirred reactor. The major reactants (CH4, O2), intermediate components (C2H6, C2H4, C2H2, H) and pollutants (CO, CO2) were measured by gas chromatography under the condition of equivalence ratio range of 02-2, oxygen content of 2%-8%, carbon dioxide content of 0-20%, water vapor content of 0-20%. The effects of various compositions on species distributions during methane oxidation were analyzed in detail. It was found that the concentration of intermediate components increased with the increase of equivalence ratio and oxygen content; the increase of carbon dioxide content had a weak inhibitory effect on the formation of intermediate products, but resulted in obvious rise of the concentration of pollutants; the increase of water vapor content led to significant increase of hydrogen production, and promoted the formation of carbon monoxide, but had little effect on the formation of carbon dioxide.
- methane /
- composition variance /
- intermediate species /
- pollutant emission /
- ,jet stirred reactor

HTML

参考文献(18)

[1]	TAN Y,DAGAUT P,CATHONNET M,et al.Natural gas and blends oxidation and ignition:experiments and modeling［J］.Symposium (International) on Combustion,1994,25(1):1563-1569.
[2]	BAKALI A E,DAGAUT P,PILLIER L,et al.Experimental and modeling study of the oxidation of natural gas in a premixed flame,shock tube,and jet-stirred reactor［J］.Combustion and Flame,2004,137(1):109-128.
[3]	DAGAUT P,NICOLLE A.Experimental and detailed kinetic modeling study of hydrogen-enriched natural gas blend oxidation over extended temperature and equivalence ratio ranges［J］.Proceedings of the Combustion Institute,2005,30(2):2631-2638.
[4]	BAHRINI C,HERBINET O,GLAUDE P A,et al.Detection of some stable species during the oxidation of methane by coupling a jet-stirred reactor (JSR) to cw-CRDS［J］.Chemical Physics Letters,2012,534:1-7.
[5]	BURKE S M,METCALFE W,HERBINET O,et al.An experimental and modeling study of propene oxidation:Part 1 speciation measurements in jet-stirred and flow reactors［J］.Combustion and Flame,2014,161(11):2765-2784.
[6]	CHEN B,WANG Z,WANG J Y,et al.Exploring gasoline oxidation chemistry in jet stirred reactors［J］.Fuel,2019,236:1282-1292.
[7]	YIN G,GAO Z,HU E,et al.Comprehensive experimental and kinetic study of 2,4,4-trimethyl-1-pentene oxidation［J］.Combustion and Flame,2019,208:246-261.
[8]	YANG M,GAO Z,TANG C,et al.Nitromethane pyrolysis and oxidation in a jet-stirred reactor:experimental measurements,kinetic model validation and interpretation［J］.Fuel,2020,263:1164911-11649111.
[9]	DAGAUT P,BOETTNER J C,CATHONNET M.Chemical kinetic study of dimethylether oxidation in a jet stirred reactor from 1 to 10 atm:experiments and kinetic modeling［J］.Symposium (International) on Combustion,1996,26(1):627-632.
[10]	BATTIN-LECLERC F,FOURNET R,GLAUDE P A,et al.Modeling of the gas-phase oxidation of n-decane from 550 to 1 600 K［J］.Proceedings of the Combustion Institute,2000,28:1597-1605.
[11]	GAO Z,HU E,XU Z,et al.Low to intermediate temperature oxidation studies of dimethoxymethane/n-heptane blends in a jet-stirred reactor［J］.Combustion and Flame,2019,207:20-35.
[12]	ZOU J B,LI W,YE L L,et al.Exploring the low-temperature oxidation chemistry of cyclohexane in a jet-stirred reactor:an experimental and kinetic modeling study［J］.Chinese Journal of Chemical Physics,2018,31(4):537-546.
[13]	DAGAUT P,GAILL S.Chemical kinetic study of the effect of a biofuel additive on jet-A1 combustion［J］.Journal of Chemical Physics,2007,111:3992-4000.
[14]	LIU Y X,DAN Y,TIAN D X,et al.An experimental and modeling study of oxidation of 1,2,4-trimethylcyclohexane with JSR［J］.Proceedings of the Combustion Institute,2019,37(1):437-444.
[15]	GALMICHE B,TOGBE C,DAGAUT P,et al.Experimental and detailed kinetic modeling study of the oxidation of 1-propanol in a pressurized jet-stirred reactor (JSR) and a combustion bomb［J］.Energy and Fuels,2011,25:2013-2021.
[16]	VELOO P S,DAGAUT P,TOGBE C,et al.Jet-stirred reactor and flame studies of propanal oxidation［J］.Proceedings of the Combustion Institute,2013,34(1):599-606.
[17]	SERINYEL Z,TOGBé C,ZARAS A,et al.Kinetics of oxidation of cyclohexanone in a jet-stirred reactor:experimental and modeling［J］.Proceedings of the Combustion Institute,2015,35(1):507-514.
[18]	LIAO H D,TAO T,SUN W Y,et al.Investigation of the low-temperature oxidation of n-butanal in a jet-stirred reactor［J］.Proceedings of the Combustion Institute,2019，37(1):453-460.