Volume 32 Issue 9
Sep.  2017
Turn off MathJax
Article Contents
Article Navigation >  Journal of Aerospace Power  > 2017  >  32(9): 2265-2272
Unsteady analysis of effect on hydraulic turbine under variable gas content[J]. Journal of Aerospace Power, 2017, 32(9): 2265-2272. doi: 10.13224/j.cnki.jasp.2017.09.027
Citation: Unsteady analysis of effect on hydraulic turbine under variable gas content[J]. Journal of Aerospace Power, 2017, 32(9): 2265-2272. doi: 10.13224/j.cnki.jasp.2017.09.027
shu

Unsteady analysis of effect on hydraulic turbine under variable gas content

doi: 10.13224/j.cnki.jasp.2017.09.027
  • Received Date: 2016-10-10
  • Publish Date: 2017-09-28
    Abstract
  • In order to study the effect of gas content on the internal pressure in hydraulic turbine, CFD technology was used to simulate the flow field in a pump with the specific speed of 845 as turbine, the distribution of gas and the effect of gas content on pressure fluctuation in hydraulic turbine were clarified. Results showed that from volume inlet to impeller outlet, the gas content increased gradually, when the gas content was equal to 02, the gas distribution was not uniform, and in volume outlet and impeller inlet the wake effect was obvious. The gas gathered in impeller outlet, the higher gas rate indicated the more obvious gathering phenomenon. The influence of gas content on the distribution of relative pressure was obvious, the relative pressure of each point in hydraulic turbine decreased with the increase in gas rate. The gas content had little effect on the pressure fluctuation amplitude of the monitored point at the main frequency when the inlet gas content was less than 005, but when the inlet gas content was greater than 005, the effect was obvious. The bigger gas content meant the smaller pressure fluctuation frequency amplitude. In different gas content the main frequencies of pressure fluctuation in turbine volute and impeller were equal to the rotation frequency of the impeller blades.

     

    • FullText(HTML)
  • loading
    • References(19)
  • [1]
    DERAKHSHAN S,NOURBAKHSH A.Experimental study of characteristic curves of centrifugal pumps working as turbines in different specific speeds［J］.Experimental Thermal and Fluid Science，2008,32(3):800-807.
    [2]
    杨孙圣,孔繁余,宿向辉,等.泵及泵用作透平时的数模拟与外特性实验［J］.西安交通大学学报， 2012,46(3):36-41. YANG Sunsheng，KONG Fanyu，SU Xianghui,et al.Numerical simulation and performance experiment on pump and pump as turbine［J］.Journal of Xian Jiao Tong University,2012,46(3):36-41.(in Chinese)
    [3]
    VENTRONE G,ARDIZZON G， PAVESI G.Direct and reverse flow conditions in radial flow hydraulic turbomachines［J］.Proceedings of the Institution of Mechanical Engineers：Part A Journal of Power and Energy,2000,214(6):635-644.
    [4]
    FERNANDEZ J,BLANCO E,PARRONDO J,et al.Performance of a centrifugal pump running in inverse mode［J］.Journal of Power and Energy,2010,18(4): 265-271.
    [5]
    DERAKHSHAN S,NOURBAKHSH A.Theoretical,numerical and experimental investigation of centrifugal pumps in reverse operation［J］.Experimental Thermal and Fluid Science,2008,32 (8):1620-1627.
    [6]
    SINGH P,NESTMANN F.An optimization routine on a prediction and selection model for the turbine operation of centrifugal pumps［J］.Experimental Thermal and Fluid Science,2010,34(2):152-164.
    [7]
    SINGH P,NESTMANN F.Internal hydraulic analysis of impeller rounding in centrifugal pumps as turbines［J］.Experimental Thermal and Fluid Science,2011,35(1):121-134.
    [8]
    新宾仁.逆运转的水泵作为水轮机运行的研究［J］.国外大电机，2000（2）:72-77. XIN Binren．Study of pumps as turbines［J］．External Big Motor，2000(2)：72-77．(in Chinese)
    [9]
    杨孙圣，孔繁余，薛玲，等.长短叶片对液力透平性能的影响［J］.农业机械学报，2012,43（7）:104-107. YANG Sunsheng,KONG Fanyu,XUE Ling,et al.Effect of splitter blade on the performance of pump as turbine［J］.Transaction of the Chinese Society for Agricultural Machinery,2012,43（7）:104-107.(in Chinese)
    [10]
    王桃,孔繁余,袁寿其,等.前弯叶片液力透平专用叶轮设计与实验［J］.农业机械学报，2014,45(12):75-79. WANG Tao,KONG Fanyu,YUAN Shouqi,et al.Design and experiment on pump as turbine with forward curved blades［J］.Transaction of the Chinese Society for Agricultural Machinery,2014,45(12):75-79.(in Chinese)
    [11]
    史广泰，杨军虎，苗森春，等.不同导叶数下液力透平蜗壳内压力脉动计算［J］.航空动力学报，2015,30(5):1228-1235. SHI Guangtai,YANG Junhu,MIAO Senchun,et al.Calculation of pressure fluctuation within volute of hydraulic turbine under different guide vane numbers［J］.Journal of Aerospace Power,2015,30(5):1228-1235.(in Chinese)
    [12]
    史广泰，杨军虎，苗森春,等.不同进口截面下液力透平非定常压力脉动计算［J］.航空动力学报，2016,31(3):659-668. SHI Guangtai,YANG Junhu,MIAO Senchun,et al.Unsteady calculation of pressure pulsation within hydraulic turbine under different entrance sections［J］.Journal of Aerospace Power,2016,31(3):659-668.(in Chinese)
    [13]
    付强，习毅，朱荣生,等.含气率对AP1000核主泵影响的非定常分析［J］.振动与冲击，2015,34(6):132-136. FU Qiang,XI Yi,ZHU Rongsheng,et al.AP1000 nuclear main pump internal unsteady analysis under gasliquid two phase condition［J］.Journal of Vibration and Shock,2015,34(6):132-136.(in Chinese)
    [14]
    SI Huang,SU Xianghui,GUO Jing,et al.Unsteady numerical simulation for gasliquid twophase flow in selfpriming process of centrifugal pump［J］.Energy Conversion and Management,2014,85(9):694-700.
    [15]
    付强，袁寿其，朱荣生,等.离心泵气液混输瞬态过渡过程水力特性研究［J］.哈尔滨工程大学学报,2012,33（11）:1428-1434. FU Qiang，YUAN Shouqi，ZHU Rongsheng，et al.Hydraulic characteristics of transient transition process of gasliquid mixed flow in a centrifugal pump［J］.Journal of Harbin Engineering University,2012,33(11): 1428-1434.(in Chinese)
    [16]
    李贵东,王洋,郑意,等.气液两相条件下离心泵内部流态及受力分析［J］.排灌机械工程学,2016,34(5):369-374. LI Guidong,WANG Yang,ZHENG Yi,et al.Unsteady internal flow and thrust analysis of centrifugal pump under gas liquid two phase flow condition［J］.Journal of Drainage and Irrigation Machinery Engineering,2016,34(5):369-374.(in Chinese)
    [17]
    杨军虎，夏书强.液力透平介质含气工况的数值分析［J］.兰州理工大学学报，2013,39(6):49-54. YANG Junhu,XIA Shuqiang.Numerical analysis of hydraulic turbine operation with gascontained medium［J］.Journal of Lanzhou University of Technology,2013,39(6):49-54.(in Chinese)
    [18]
    杨军虎，许亭.气液两相介质的多级液力透平特性［J］.兰州理工大学学报，2015,41(2):45-50. YANG Junhu,XU Ting.Performance for multistage hydraulic turbine with gasliquid twophase media［J］.Journal of Lanzhou University of Technology,2015,41(2):45-50.(in Chinese)
    [19]
    阎昌琪.气液两相流［M］.哈尔滨：哈尔滨工程大学出版社，2009.
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF(1073.0KB)
    XML

    Article Metrics

    Article views (771) PDF downloads(395) Cited by()
    Proportional views
    Related

    Copyright © 《Journal of Aerospace Power》 All Rights Reserved.

    Supported by: Beijing Renhe Information Technology Co., Ltd.  

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return