Volume 34 Issue 10
Oct.  2019
Turn off MathJax
Article Contents
Article Navigation >  Journal of Aerospace Power  > 2019  >  34(10): 2280-2293
LI Jianan, LEI Fanpei. Effects of misaligned impingement on atomization characteristics of impinging jet injector[J]. Journal of Aerospace Power, 2019, 34(10): 2280-2293. doi: 10.13224/j.cnki.jasp.2019.10.022
Citation: LI Jianan, LEI Fanpei. Effects of misaligned impingement on atomization characteristics of impinging jet injector[J]. Journal of Aerospace Power, 2019, 34(10): 2280-2293. doi: 10.13224/j.cnki.jasp.2019.10.022
shu

Effects of misaligned impingement on atomization characteristics of impinging jet injector

doi: 10.13224/j.cnki.jasp.2019.10.022
  • 1.

    Science and Technology on Liquid Rocket Engine Laboratory,Xi’an Aerospace Propulsion Institute,China Aerospace Sicence and Technology Corporation,Xi’an 710100,China

  • 2.

    China State Shipbuilding Corporation Limited,Beijing 100044,China

  • Received Date: 2019-02-19
  • Publish Date: 2019-10-28
    Abstract
  • In order to investigate the effects of misaligned impingement on the atomization characteristics of impinging jet injector, a numerical scheme to simulate cold atomization process of hypergolic propellants was established. Also atomization process with different misaligned degrees was simulated. Incompressible Navier-Stokes equations were directly solved by employing tree-based adaptive refinement algorithm. Interfaces of different fluids were captured by piecewise linear volume-of-fluid (VOF) method. The results revealed that atomization field was deflected due to misaligned impingement. When the dimensionless misaligned degree E was 1/8, the deflection angle of the atomization filed was about 9.2°, so the machining deviation should be controlled below this value. The deflected angle increased with the misaligned degree. The angle obtained by theoretical analysis was smaller than that of numerical simulation. When aligned impingement occurred, mass flow rate flux peaks of fuel and oxide were close in space and unimodal distribution of the total mass flow rate flux appeared. When misaligned impingement occurred, for the reason that partial momentums of fuel and oxide jet didn’t participate in impingement, mass flow rate flux distribution of fuel and oxide interlaced and bimodal distribution of the total mass flow rate flux appeared. Mixture ratio distribution in space changed a lot. Droplet velocity distribution of aligned impingement downstream the impingement point was approximately axial symmetric while that of misaligned impingement was approximately central symmetric. Jet momentum loss caused by misaligned impingement led to poorer atomization performance. When dimensionless misaligned degree E was 1/8, Sauter mean diameter of monomethylhydrazine(MMH) increased about 4.8% and that of nitrogen tetroxide(NTO) increased about 5.8%.

     

    • FullText(HTML)
  • loading
    • References(38)
  • [1]
    HEIDMANN M F,PRIEM R J,HUMPHREY J C.A study of sprays formed by two impinging jets［R］.NACA (National Advisory Committee for Aeronautics) TN3835,1957.
    [2]
    HEIDMANN M F,HUMPHREY J C.Fluctuations in a spray formed by two impinging jets［R］.NACA (National Advisory Committee for Aeronautics) TN2349,1951.
    [3]
    ANDERSON W E,RYAN H M,SANTORO R J.Impact wave-based model of impinging jet atomization［J］.Atomization and Sprays,2006,16(7):791-805.
    [4]
    RYAN H M,ANDERSON W E,PAL S,et al.Atomization characteristics of impinging liquid jets［J］.Journal of Propulsion and Power,1995,11(1):135-145.
    [5]
    LI R,ASHGRIZ N.Characteristics of liquid sheets formed by two impinging jets［J］.Physics of Fluids,2006,18(8):087104.1-087104.13
    [6]
    PANO M R O,DELGADO J M D.Effect of pre-impingement length and misalignment in the hydrodynamics of multijet impingement atomization［J］.Physics of Fluids,2013,25(1):012105.1-012105.11
    [7]
    SUBEDI B,SON M,KIM W,et al.Spray characteristics of misaligned impinging injectors［J］.Journal of the Korean Society of Marine Engineering,2014,38(10):1257-1262.
    [8]
    邓寒玉,封锋,武晓松,等.射流偏心撞击对凝胶推进剂撞击雾化影响的实验研究［J］.兵工学报,2016,37(4):612-620.DENG Hanyu,FENG Feng,WU Xiaosong,et al.Experimental research on the effect of eccentric impact of jet on the impinging atomization of gel propellant［J］.Acta Armamentarii,2016,37(4):612-620.(in Chinese)
    [9]
    INOUE C,WATANABE T,HIMENO T.Study on atomization process of liquid sheet formed by impinging jets［R］.AIAA 2008-4847,2008.
    [10]
    ARIENTI M,LI X,SOTERIOU M C,et al.Coupled level-set/volume-of-fluid method for the simulation of liquid atomization in propulsion device injectors［R］.AIAA 2010-7136,2010.
    [11]
    CHEN X D,MA D J,YANG V.Mechanism study of impact wave in impinging jets atomization［R］.AIAA 2012-1089,2012.
    [12]
    CHEN X D,MA D J,YANG V.High-fidelity numerical simulations of impinging jet atomization［R］.AIAA 2012-4328,2012.
    [13]
    CHEN X D,YANG V.Thickness-based adaptive mesh refinement methods for multi-phase flow simulations with thin regions［J］.Journal of Computational Physics,2014,269:22-39.
    [14]
    郑刚,聂万胜,何博,等.撞击角对撞击式喷嘴雾化特性影响研究［J］.推进技术,2015,36(4):608-613.ZHENG Gang,NIE Wansheng,HE Bo,et al.Effects of impingement angle on atomization characteristics of impinging jets injector［J］.Journal of Propulsion Technology,2015,26(4):608-613.(in Chinese)
    [15]
    郑刚,冯伟,聂万胜,等.动量比对两股互击式喷嘴雾化特征的影响［J］.航空动力学报,2016,31(9):2283-2289.ZHENG Gang,FENG Wei,NIE Wansheng,et al.Effect of momentum ratio on atomization characteristics of unlike-doublet impinging jets injector［J］.Journal of Aerospace Power,2016,31(9):2283-2289.(in Chinese)
    [16]
    ZHENG G,NIE W S,FENG S J,et al.Numerical simulation of the atomization process of a like-doublet impinging rocket injector［J］.Procedia Engineering,2015,99:930-938.
    [17]
    刘昌波,雷凡培,周立新.两股湍流射流撞击雾化过程的数值研究［J］.推进技术,2014,35(12):1669-1678.LIU Changbo,LEI Fanpei,ZHOU Lixin,et al.Primary atomization simulations of two turbulent impinging jets［J］.Journal of Propulsion Technology,2014,35(12):1669-1678.(in Chinese)
    [18]
    强洪夫,刘虎,陈福振,等.基于SPH方法的射流撞击仿真［J］.推进技术,2012,33(3):424-429.QIANG Hongfu,LIU Hu,CHEN Fuzhen,et al.Simulation on jet impingement based on SPH method［J］.Journal of Propulsion Technology,2012,33(3):424-429.(in Chinese)
    [19]
    强洪夫,韩亚伟,王广,等.幂律型流体雾化SPH方法数值分析［J］.推进技术,2013,34(2):240-247.QIANG Hongfu,HAN Yawei,WANG Guang,et al.Numerical simulationof atomization process of liquid with power law model based on SPH method［J］.Journal of Propulsion Technology,2013,34(2):240-247.(in Chinese)
    [20]
    韩亚伟,强洪夫,刘虎.双股液体射流撞击雾化的SPH方法数值模拟［J］.工程力学,2013,30(3):17-23.HAN Yawei,QIANG Hongfu,LIU Hu.Numerical simulation of two liquid impinging jets with SPHmethod［J］.Engineering Mechanics,2013,30(3):17-23.(in Chinese)
    [21]
    WEI Q,LIANG G Z.Coupled lagrangian impingement spray model for doublet impinging injectors under liquid rocket engine operating conditions［J］.Chinese Journal of Aeronautics,2017,30(4):1391-1406.
    [22]
    YUAN T,CHEN C,HUANG B.Optical observation of the impingements of nitrogentetroxide/monomethylhyd-razine simulants［J］.AIAA Journal,2006,44(10):2259-2266.
    [23]
    YUAN T,CHEN C,HUANG B.Comparison of hot-fire and cold-flow observations of nitrogentetroxide/ monomethylhydrazine impinging combustion［J］.AIAA Journal,2009,47(10):2359-2367.
    [24]
    YUAN T,CHEN C,HUANG B,et al.The impinging-type injector design of MMH/NTO liquid rocket engine［R］.AIAA 2012-3745,2012.
    [25]
    RUPE J H.An experimental correlation of the nonreactive properties of injection schemes and combustion effects in a liquid-propellant rocket engine:Part 1 the application of nonreactive-spray properties to rocket-motor injector design［R］.NASA-CR-64635,1965.
    [26]
    TANI H,DAIMON Y,SASAKI M,et al.Atomization and hypergolic reactions of impinging streams of monomethylhydrazine and dinitrogen tetroxide［J］.Combustion and Flame,2017,185:142-151.
    [27]
    POPINET S.Gerris:a tree-based adaptive solver for the incompressible euler equations in complex geometries［J］.Journal of Computational Physics,2003,190(2):572-600.
    [28]
    POPINET S.An accurate adaptive solver for surface-tension-driven interfacial flows［J］.Journal of Computational Physics,2009,228(16):5838-5866.
    [29]
    BRACKBILL J U,KOTHE D B,ZEMACH C A.A continuum method for modeling surface tension［J］.Journal of Computational Physics,1992,100(2):335-354.
    [30]
    阎超,于剑,徐晶磊,等.CFD模拟方法的发展成就与展望［J］.力学进展,2011,41(5):563-589.YAN Chao,YU Jian,XU Jinglei,et al.On the achievements and prospects for the methods of computational fluid dynamics［J］.Advances in Mechanics,2011,41(5):563-589.(in Chinese)
    [31]
    BORIS J P,GRINSTEIN F F,ORAN E S,et al.New insights into large eddy simulation［R］.NAL(Naval Research Laboratory),4400-92-6979,1992
    [32]
    HIRT C W,NICHOLS B D.Volume of fluid (VOF) method for the dynamics of free boundaries［J］.Journal of Computational Physics,1981,39(1):201-225.
    [33]
    ANDERSON W E.Theeffectsof atomization on combustion stability［D］.Philadelphia:The Pennsylvania State University,1996:30-34.
    [34]
    ANDERSON W E,RYAN H M,SANTORO R J,et al.Combustion instability mechanisms in liquid rocket engines using impinging jet injectors［R］.AIAA 95-2357,1995.
    [35]
    ZHANG P Y,WANG B.Effects of elevated ambient pressure on the disintegration of impinged sheets［J］.Physics of Fluids,2017,29:042202.1-042202.17.
    [36]
    RUPE J H.The liquid-phase mixing of impinging streams［R］.Pasadena,US:Jet Propulsion Laboratory,Progress Report,1953.
    [37]
    RUPE J H.A correlation between the dynamic properties of a pair of impinging streams and the uniformity of mixture-ratio distribution in resulting spray［R］.Pasadena,US:Jet Propulsion Laboratory,Progress Report,1956.
    [38]
    费俊,孙璠,杨伟东,等.射流撞击雾化液滴运动过程与粒径分布特性的试验研究［J］.火箭推进,2015,41(1):10-14,35.FEI Jun,SUN Fan,YANG Weidong,et al.Experimental analysis on movement and size distribution of atomized droplets from impinging liquid jet［J］.Journal of Rocket Propulsion,2015,41(1):10-14,35.(in Chinese)
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF(1168.0KB)
    XML

    Article Metrics

    Article views (709) PDF downloads(346) Cited by()
    Proportional views
    Related

    Copyright © 《Journal of Aerospace Power》 All Rights Reserved.

    Supported by: Beijing Renhe Information Technology Co., Ltd.  

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return