| Citation: | HUANG Xingrong, YANG Donglai, XIAO Kaiwen, et al. Analysis of dry friction fault caused by rotor elastic support bolt looseness[J]. Journal of Aerospace Power, 2023, 38（7）：1723-1733 doi: 10.13224/j.cnki.jasp.20210299
|
Abnormal vibration of a core engine rotor system was observed in the experimental results under different working conditions. A simplified rotor model with looseness in its front squirrel cage supporting was established based on the experimental results. Based on the rotor dynamic theory and the experimental signal characteristics, the bolt looseness of the front squirrel cage supporting was modeled by a generalized Dahl friction model following Masing rules. The orbit of shaft center, displacement of front supporting and supporting anti-force were carefully analyzed for the following three types: linear rotor system without fault; nonlinear rotor system with bolt looseness but without gyroscopic effect; nonlinear rotor system with bold looseness and gyroscopic effect. The simulation results showed that, in a rotor system with dry friction, the response of the system had rich harmonic components; the gyroscopic effect showed important influence on the harmonic components in the dynamic responses. The research results provide a reference for the monitoring and diagnosis of this type of faulty rotor system.
| [1] |
《航空发动机手册》总编委会. 航空发动机设计手册: 第19册 转子动力学及整机振动[M]. 北京: 中国航空工业出版社, 2000.
|
| [2] |
韩清凯, 于涛, 王德友, 等. 故障转子系统的非线性振动分析与诊断方法[M]. 北京: 科学出版社, 2010
|
| [3] |
罗跃纲. 转子系统故障的若干非线性动力学问题及智能诊断研究[D]. 沈阳: 东北大学, 2002.
LUO Yuegang. Study on some nonlinear dynamics problems of rotor system with faults and intelligent diagnosis method[D]. Shenyang: Northeastern University, 2002. (in Chinese)
|
| [4] |
SHANG Zhiyong,JIANG Jun,HONG Lin. The global responses characteristics of a rotor/stator rubbing system with dry friction effects[J]. Journal of Sound and Vibration,2011,330(10): 2150-2160. doi: 10.1016/j.jsv.2010.06.004
|
| [5] |
JIANG Mian,WU Jigang,PENG Xinsheng,et al. Nonlinearity measure-based assessment method for pedestal looseness of bearing-rotor systems[J]. Journal of Sound and Vibration,2017,411: 232-246. doi: 10.1016/j.jsv.2017.09.002
|
| [6] |
CHOUKSEY M,DUTT J K,MODAK S V. Modal analysis of rotor-shaft system under the influence of rotor-shaft material damping and fluid film forces[J]. Mechanism & Machine Theory,2012,48: 81-93.
|
| [7] |
WEI Songhan,LU Wenxiu,CHU Fulei. Speed characteristics of disk-shaft system with rotating part looseness[J]. Journal of Sound and Vibration,2019,469: 115-127.
|
| [8] |
JIN Yulin,LIU Zhiwen,YANG Yang,et al. Nonlinear vibrations of a dual-rotor-bearing-coupling misalignment system with blade-casing rubbing[J]. Journal of Sound and Vibration,2021,497(6): 115948.1-115948.19.
|
| [9] |
张大义,母国新,洪杰. 航空发动机转子支承系统刚度计算中的几个问题[J]. 战术导弹技术,2005(2): 20-23. doi: 10.3969/j.issn.1009-1300.2005.02.004
ZHANG Dayi,MU Guoxin,HONG Jie. Rigidity calculation methods for rotor supporting system in gas engine[J]. Tactical Missile Technology,2005(2): 20-23. (in Chinese) doi: 10.3969/j.issn.1009-1300.2005.02.004
|
| [10] |
MA Hui, SUN Wei, DAI Jishuang, et al. Fault feature analysis of rotor system with looseness fault[C]//Proceedings of the ASME 2009 International Design Engineering Technical Conferences and Computers and Information in Engineering Conference. Volume 1: 22nd Biennial Conference on Mechanical Vibration and Noise, Parts A and B. San Diego, California, US: ASME, 2009: 1073-1077.
|
| [11] |
姚红良,刘长利,张晓伟,等. 支承松动故障转子系统共振区动态特性分析[J]. 东北大学学报(自然科学版),2003,24(8): 798-801. doi: 10.3321/j.issn:1005-3026.2003.08.023
YAO Hongliang,LIU Changli,ZHANG Xiaowei,et al. Dynamics of pedestal looseness rotor system near the critical speed region[J]. Journal of Northeastern University (Natural Science),2003,24(8): 798-801. (in Chinese) doi: 10.3321/j.issn:1005-3026.2003.08.023
|
| [12] |
王海飞,陈果,廖仲坤,等. 含支承松动故障的航空发动机非同步响应特征[J]. 振动、测试与诊断,2016,36(5): 858-864. doi: 10.16450/j.cnki.issn.1004-6801.2016.05.007
WANG Haifei,CHEN Guo,LIAO Zhongkun,et al. Asynchronous response characteristics of aeroengine with support looseness fault[J]. Journal of Vibration, Measurement & Diagnosis,2016,36(5): 858-864. (in Chinese) doi: 10.16450/j.cnki.issn.1004-6801.2016.05.007
|
| [13] |
YANG Yang,YANG Yiren,CAO Dengqing,et al. Response evaluation of imbalance-rub-pedestal looseness coupling fault on a geometrically nonlinear rotor system[J]. Mechanical Systems and Signal Processing,2018,118: 423-442.
|
| [14] |
李振平,罗跃纲,姚红良,等. 转子系统支承松动的非线性动力学及故障特征[J]. 东北大学学报,2002,23(11): 1048-1051.
LI Zhenping,LUO Yuegang,YAO Hongliang,et al. Nonlinear dynamics and fault characteristics of rotor system with support looseness[J]. Journal of Northeastern University,2002,23(11): 1048-1051. (in Chinese)
|
| [15] |
丁一. 含挤压油膜阻尼器支承转子特性分析和减振机理探究[D]. 南京: 南京航空航天大学, 2018.
DING Yi. Analysis of rotor characteristics with squeeze film damper bearing and research on the damping mechanism[D]. Nanjing: Nanjing University of Aeronatics and Astronautics, 2018. (in Chinese)
|
| [16] |
MA Hui,SHI Chaoyang,HAN Qingkai,et al. Fixed-point rubbing fault characteristic analysis of a rotor system based on contact theory[J]. Mechanical Systems and Signal Processing,2013,38(1): 137-153. doi: 10.1016/j.ymssp.2012.10.009
|
| [17] |
HONG Jie,YU Pingchao,ZHANG Dayi,et al. Nonlinear dynamic analysis using the complex nonlinear modes for a rotor system with an additional constraint due to rub-impact[J]. Mechanical Systems and Signal Processing,2019,116: 443-461. doi: 10.1016/j.ymssp.2018.06.061
|
| [18] |
刘杨,太兴宇,马辉,等. 双盘三支撑转子轴承系统松动-碰摩耦合故障分析[J]. 航空动力学报,2013,28(8): 977-982. doi: 10.13224/j.cnki.jasp.2013.05.003
LIU Yang,TAI Xingyu,MA Hui,et al. Looseness-rubbing coupling fault of dual-disk three-support rotor-bearing system[J]. Journal of Aerospace Power,2013,28(8): 977-982. (in Chinese) doi: 10.13224/j.cnki.jasp.2013.05.003
|
| [19] |
YANG Yang,OUYANG Huajiang,YANG Yiren,et al. Vibration analysis of a dual-rotor-bearing-double casing system with pedestal looseness and multi-stage turbine blade-casing rub[J]. Mechanical Systems and Signal Processing,2019,143(4): 106845.1-106845.25.
|
| [20] |
罗忠,王晋雯,韩清凯,等. 组合支承转子系统动力学的研究进展[J]. 机械工程学报,2021,57(7): 44-60. doi: 10.3901/JME.2021.07.044
LUO Zhong,WANG Jinwen,HAN Qingkai,et al. Research progress on dynamics of combined support rotor system[J]. Journal of Mechanical Engineering,2021,57(7): 44-60. (in Chinese) doi: 10.3901/JME.2021.07.044
|
DownLoad:
