| Citation: | DING Xiaofei, LIAO Mingfu, PENG Danyang, et al. Experimental validation of the beat vibration of aero-engine[J]. Journal of Aerospace Power, 2023, 38（11）：2639-2647 doi: 10.13224/j.cnki.jasp.20220112
|
Combined with theoretical simulation of the beat vibration, analysis of the measured vibration signal and summary of the actual vibration elimination experience, three multi-source beat vibration modes of aero-engines were discussed. The identification process and the elimination method of the beat vibration fault were established. Experimental verification showed that for the three common multi-source coupling beat modes, the multi-source beat vibration and the vibration fluctuation could be eliminated when the multi-source excitation frequency differed by more than 3%. The proposed process and method were implemented and verified in engine beat vibration and fluctuation trouble-shooting, and the low-pressure rotor 2 times frequency-high-pressure rotor fundamental frequency coupled beat vibration was accurately identified. The low-pressure rotor speed was well-tuned through the control schedule to separate the above two frequencies by 3%. The vibration fluctuations caused by beat vibration was eliminated and the proposed method was validated.
| [1] |
廖明夫,于潇,王四季,等. 双转子系统的振动[J]. 机械科学与技术,2013,32(4): 475-480. doi: 10.13433/j.cnki.1003-8728.2013.04.020
LIAO Mingfu,YU Xiao,WANG Siji,et al. The vibration features of a twin spool rotor system[J]. Mechanical Science and Technology for Aerospace Engineering,2013,32(4): 475-480. (in Chinese) doi: 10.13433/j.cnki.1003-8728.2013.04.020
|
| [2] |
刘永泉,王德友,洪杰,等. 航空发动机整机振动控制技术分析[J]. 航空发动机,2013,39(5): 1-8, 13.
LIU Yongquan,WANG Deyou,HONG Jie,et al. Analysis of whole aeroengine vibration control technology[J]. Aeroengine,2013,39(5): 1-8, 13. (in Chinese)
|
| [3] |
艾延廷,周海仑,孙丹,等. 航空发动机整机振动分析与控制[J]. 沈阳航空航天大学学报,2015,32(5): 1-25. doi: 10.3969/j.issn.2095-1248.2015.05.001
AI Yanting,ZHOU Hailun,SUN Dan,et al. Study on the contol of the whole aero-engine vibration[J]. Journal of Shenyang Aerospace University,2015,32(5): 1-25. (in Chinese) doi: 10.3969/j.issn.2095-1248.2015.05.001
|
| [4] |
陈曦,廖明夫,张霞妹,等. 大涵道比涡扇发动机低压转子现场动平衡技术[J]. 航空动力学报,2017,32(4): 808-819.
CHEN Xi,LIAO Mingfu,ZHANG Xiamei,et al. Field balancing technology for low pressure rotors of high bypass ratio turbofan engines[J]. Journal of Aerospace Power,2017,32(4): 808-819. (in Chinese)
|
| [5] |
PENNACCHI P,VANIA A,BACHSCHMID N. Increasing the robustness of fault identification in rotor dynamics by means of Mestimators[J]. Mechanical Systems and Signal Processing,2007,21(8): 3003-3029. doi: 10.1016/j.ymssp.2007.04.001
|
| [6] |
李全坤,廖明夫,蒋云帆. 双转子不对中故障振动特性分析[J]. 机械科学与技术,2014,33(12): 1916-1920.
LI Quankun,LIAO Mingfu,JIANG Yunfan. The vibration features analysis of twin spool rotor with misalignment fault[J]. Mechanical Science and Technology for Aerospace Engineering,2014,33(12): 1916-1920. (in Chinese)
|
| [7] |
张宏献,李学军,蒋玲莉,等. 航空发动机双转子系统不对中研究进展[J]. 航空学报,2019,40(6): 022717.
ZHANG Hongxian,LI Xuejun,JIANG Lingli,et al. A review of misalignment of aero-engine rotor system[J]. Acta Aeronautica et Astronautica Sinica,2019,40(6): 022717. (in Chinese)
|
| [8] |
马艳红,刘海舟,邓旺群,等. 具有初始热变形的转子系统振动响应分析[J]. 北京航空航天大学学报,2019,45(2): 227-233. doi: 10.13700/j.bh.1001-5965.2018.0309
MA Yanhong,LIU Haizhou,DENG Wangqun,et al. Vibration response analysis of rotor system with initial thermal deformation[J]. Journal of Beijing University of Aeronautics and Astronautics,2019,45(2): 227-233. (in Chinese) doi: 10.13700/j.bh.1001-5965.2018.0309
|
| [9] |
BACHSCHMID N,PENNACCHI P,VANIA A. Thermally induced vibrations due to rub in real rotors[J]. Journal of Sound and Vibration,2007,299(4/5): 683-719.
|
| [10] |
PENNACCHI P,VANIA A. Accuracy in the identification of a generator thermal bow[J]. Journal of Sound and Vibration,2004,274(1/2): 273-295.
|
| [11] |
廖明夫,宋明波,张霞妹. 转子/机匣碰摩引起的转子弯扭耦合振动[J]. 振动、测试与诊断,2016,36(5): 1009-1017, 1031.
LIAO Mingfu,SONG Mingbo,ZHANG Xiamei. Coupled bending and torsional vibration due to rotor-casing contact[J]. Journal of Vibration, Measurement & Diagnosis,2016,36(5): 1009-1017, 1031. (in Chinese)
|
| [12] |
王俨剀,王理,廖明夫,等. 双转子发动机转子-机匣碰摩振动特征研究[J]. 机械科学与技术,2014,33(4): 614-620.
WANG Yankai,WANG Li,LIAO Mingfu,et al. Exploring vibration characteristics of dual-rotor engine’s rotor-to-case rub-impact[J]. Mechanical Science and Technology for Aerospace Engineering,2014,33(4): 614-620. (in Chinese)
|
| [13] |
丁小飞,曹航,冯国全,等. 航空发动机转子盘腔积油振动故障分析[J]. 航空动力学报,2021,36(2): 341-351. doi: 10.13224/j.cnki.jasp.2021.02.012
DING Xiaofei,CAO Hang,FENG Guoquan,et al. Vibration fault analysis of aeroengine rotor disk cavity filled with oil[J]. Journal of Aerospace Power,2021,36(2): 341-351. (in Chinese) doi: 10.13224/j.cnki.jasp.2021.02.012
|
| [14] |
韩军,高德平,胡绚,等. 航空发动机双转子系统的拍振分析[J]. 航空学报,2007,28(6): 1369-1373.
HAN Jun,GAO Deping,HU Xuan,et al. Research on beat vibration of dual-rotor for aero-engine[J]. Acta Aeronautica et Astronautica Sinica,2007,28(6): 1369-1373. (in Chinese)
|
| [15] |
钱征文,程礼,范家栋,等. 某型航空发动机振动值摆动故障诊断[J]. 振动、测试与诊断,2012,32(2): 208-213, 339.
QIAN Zhengwen,CHENG Li,FAN Jiadong,et al. Fault diagnosis of vibration amplitude swing for some kind of aeroengine[J]. Journal of Vibration, Measurement & Diagnosis,2012,32(2): 208-213, 339. (in Chinese)
|
| [16] |
马进锐. 航空发动机故障诊断与振动预测技术研究[D]. 西安: 西北工业大学, 2015.
MA Jinrui. Aero engine fault diagnosis and vibration prediction[D]. Xi’an: Northwestern Polytechnical University, 2015. (in Chinese)
|
| [17] |
陈茉莉,李舜酩,温卫东,等. 多源拍振分析方法与试验[J]. 振动、测试与诊断,2011,31(2): 202-206, 267.
CHEN Moli,LI Shunming,WEN Weidong,et al. Analysis and experiment on multi-source beat vibration[J]. Journal of Vibration, Measurement & Diagnosis,2011,31(2): 202-206, 267. (in Chinese)
|
| [18] |
王俨剀, 廖明夫, 丁小飞. 航空发动机故障诊断[M]. 北京: 科学出版社, 2020.
|
| [19] |
廖明夫. 航空发动机转子动力学[M]. 西安: 西北工业大学出版社, 2015.
|
| [20] |
王俨剀,张占升,廖明夫,等. 基于动力学分析的发动机测振截面选取[J]. 航空动力学报,2018,33(6): 1446-1455. doi: 10.13224/j.cnki.jasp.2018.06.018
WANG Yankai,ZHANG Zhansheng,LIAO Mingfu,et al. Section selecting for engine vibration measurement based on dynamic analysis[J]. Journal of Aerospace Power,2018,33(6): 1446-1455. (in Chinese) doi: 10.13224/j.cnki.jasp.2018.06.018
|
DownLoad:
