| Citation: | LI Li, BAI Junqiang, LIU Chaoyu, et al. Conceptual sizing method and energy management strategy of serial hybrid-electric aircraft[J]. Journal of Aerospace Power, 2023, 38（5）：1143-1156 doi: 10.13224/j.cnki.jasp.20220901
|
For serial hybrid-electric aircraft (HEA), the flight performance of the whole aircraft was analyzed in combination with the dynamic characteristics within the given mission profile, and the overall parameters were associated with power and energy demand in each flight stage, assisting in design and sizing of each system component. Then, the calculation logic and each work path for the serial hybrid electric propulsion (HEP) system were summarized to explore the potential impact of energy management strategy (EMS) on the sizing method. Based on the established design system, a Dornier Do 228NG aircraft was selected and applied to compare the proposed method with that developed by two European teams from three design aspects. The results showed that the relative error for design point was less than 1.5%, the errors for conventional powertrain design were under 6%, and the evaluation of maximum takeoff mass (MTOM) for serial HEP design was less than 4% error. And it can verify the feasibility and effectiveness of our method. The characteristics, advantages and disadvantages of four EMS were analyzed and discussed. And based on an existing serial HEA, the Panthera Hybrid, the differences of power system working situation and design parameters under distinct strategies were studied and summarized. The results indicated that the MTOM under Light strategy was the smallest, and the benefits lied in that the maximum power demand during the take-off was taken by the fuel and battery power system at the same time, which optimized the power system weight directly.
| [1] |
中华人民共和国国务院. 关于完整准确全面贯彻新发展理念做好碳达峰碳中和工作的意见[EB/OL]. [2022-11-15]. http: //www.gov.cn/zhengce/2021-10/24/content_5644613.htm.
|
| [2] |
中华人民共和国国家发展和改革委员会. 中华人民共和国国民经济和社会发展第十四个五年规划和2035年远景目标纲要[EB/OL]. [2022-11-15]. http: //www.gov.cn/xinwen/2021-03/13/content_5592681.htm.
|
| [3] |
IGONZÁLEZ R K. Report of the executive committee on agenda item 17[C]//International Civil Aviation Organization 37th Assembly Working Papers. Montreal, Canada: International Civil Aviation Organization, 2010: 1-17.
|
| [4] |
RIBEIRO J,AFONSO F,RIBEIRO I,et al. Environmental assessment of hybrid-electric propulsion in conceptual aircraft design[J]. Journal of Cleaner Production,2020,247: 1-13.
|
| [5] |
黄俊,杨凤田. 新能源电动飞机发展与挑战[J]. 航空学报,2016,37(1): 57-68.
HUANG Jun,YANG Fengtian. Development and challenges of electric aircraft with new energies[J]. Acta Aeronautica et Astronautica Sinica,2016,37(1): 57-68. (in Chinese)
|
| [6] |
钱煜平,张扬军. 航空混合电推进系统中的热管理问题分析[J]. 航空动力,2019(6): 36-40.
QIAN Yuping,ZHANG Yangjun. Analysis of thermal management in aviation hybrid electric propulsion system[J]. Aerospace Power,2019(6): 36-40. (in Chinese)
|
| [7] |
康桂文,胡雨. 超轻型电动飞机电动力系统的参数匹配[J]. 航空动力学报,2013,28(12): 2641-2647. doi: 10.13224/j.cnki.jasp.2013.12.002
KANG Guiwen,HU Yu. Parameters matching of ultralight electric aircraft propulsion system[J]. Journal of Aerospace Power,2013,28(12): 2641-2647. (in Chinese) doi: 10.13224/j.cnki.jasp.2013.12.002
|
| [8] |
PORNET C,ISIKVEREN A F. Conceptual design of hybrid-electric transport aircraft[J]. Progress in Aerospace Sciences,2015,79(4): 114-135.
|
| [9] |
XIE Y,SAVVARISAL A,TSOURDOS A,et al. Review of hybrid electric powered aircraft, its conceptual design and energy management methodologies[J]. Chinese Journal of Aeronautics,2021,34(4): 432-450. doi: 10.1016/j.cja.2020.07.017
|
| [10] |
RENDÓN R A,SÁNCHEZ R C D,GALLO M J,et al. Aircraft hybrid-electric propulsion: development trends, challenges and opportunities[J]. Journal of Control, Automation and Electrical Systems,2021,32(5): 1244-1268. doi: 10.1007/s40313-021-00740-x
|
| [11] |
李龙,王鹏. 混合电推进系统关键技术研究进展[J]. 燃气涡轮试验与研究,2021,34(3): 49-53. doi: 10.3969/j.issn.1672-2620.2021.03.010
LI Long,WANG Peng. Development of key technologies for hybrid electric propulsion system[J]. Gas Turbine Experiment and Research,2021,34(3): 49-53. (in Chinese) doi: 10.3969/j.issn.1672-2620.2021.03.010
|
| [12] |
VOSKUIJL M,VAN BOGAERT J,RAO A G. Analysis and design of hybrid electric regional turboprop aircraft[J]. CEAS Aeronaut Journal,2018,9: 15-25. doi: 10.1007/s13272-017-0272-1
|
| [13] |
LIU Y, WANG H, ZHANG J, et al. Retrofit and new design of regional aircraft with hybrid electric propulsion[R]. Virtual: AIAA Propulsion and Energy 2021 Forum, 2021.
|
| [14] |
BOGGERO L,FIORITI M,CORPINO S. Development of a new conceptual design methodology for parallel hybrid aircraft[J]. Journal of Aerospace Engineering,2019,233(3): 1047-1058.
|
| [15] |
HARMON F G,FRANK A A,CHATTOT J J. Conceptual design and simulation of a small hybrid-electric unmanned aerial vehicle [J]. Journal of Aircraft,2006,43(5): 1490-1498. doi: 10.2514/1.15816
|
| [16] |
HUNG J Y,GONZALEZ L F. On parallel hybrid-electric propulsion system for unmanned aerial vehicles[J]. Progress in Aerospace Sciences,2012,51(1): 1-17.
|
| [17] |
陈刚,贾玉红,马东立,等. 垂直起降固定翼无人机串联混电系统优化设计[J]. 北京航空航天大学学报,2021,47(4): 742-753. doi: 10.13700/j.bh.1001-5965.2020.0015
CHEN Gang,JIA Yuhong,MA Dongli,et al. Optimal design of series-hybrid electric system for unmanned convertiplane[J]. Journal of Beijing University of Aeronautics and Astronautics,2021,47(4): 742-753. (in Chinese) doi: 10.13700/j.bh.1001-5965.2020.0015
|
| [18] |
李正浩. 通用飞机油电混合动力系统优化与仿真[D]. 沈阳: 沈阳航空航天大学, 2016.
LI Zhenghao. Optimization and simulation of general aircraft hybrid-electric system[D]. Shenyang: Shenyang Aerospace University, 2016. (in Chinese)
|
| [19] |
SAVVARIS A,XIE Y,WANG L,et al. Control and optimisation of hybrid electric propulsion system for light aircraft[J]. The Journal of Engineering,2018,2018(13): 478-483. doi: 10.1049/joe.2018.0013
|
| [20] |
SALTER R, FALCONE J, BONET J. Parallel hybrid electric propulsion demonstrator concept[R]. Virtual: AIAA Scitech 2021 Forum, 2021.
|
| [21] |
FINGER D F,BRAUN C,BIL C. Comparative assessment of parallel-hybrid-electric propulsion systems for four different aircraft[J]. Journal of Aircraft,2020,57(5): 843-852. doi: 10.2514/1.C035897
|
| [22] |
WALL T J,MEYER R T. Hybrid electric aircraft switched model optimal control[J]. Journal of Propulsion and Power,2020,36(4): 488-497. doi: 10.2514/1.B37419
|
| [23] |
PAUR J. Siemens builds the Chevrolet volt of airplanes[EB/OL]. [2022-11-15].https: //www.wired.com/2011/06/electric-airplane-uses-hybrid-power-similar-to-chevy-volt/.
|
| [24] |
SIGLER D. Pipistrel leads MAHEPA: european hybrid research[EB/OL]. [2022-11-15]. http://sustainableskies.org/pipistrel-leads-mahepa-european-hybrid-research/.
|
| [25] |
李也. 通用飞机混合电推进系统方案设计及性能分析[D]. 北京: 清华大学, 2019.
LI Ye. Design and performance analysis of general aircraft hybrid electric propulsion system[D]. Beijing: Tsinghua University, 2019. (in Chinese)
|
| [26] |
DE VRIES R,BROWN M,VOS R. Preliminary sizing method for hybrid-electric distributed-propulsion aircraft[J]. Journal of Aircraft,2019,56(6): 2172-2188. doi: 10.2514/1.C035388
|
| [27] |
FINGER D F,BIL C,BRAUN C. Initial sizing methodology for hybrid-electric general aviation aircraft[J]. Journal of Aircraft,2020,57(2): 245-255. doi: 10.2514/1.C035428
|
| [28] |
宗建安,朱炳杰,侯中喜,等. 固旋翼垂直起降混电飞行器推进系统设计[J]. 航空学报,2022,43(5): 225395.1-225395.12.
ZONG Jianan,ZHU Bingjie,HOU Zhongxi,et al. A design method of hybrid-electric fixed-wing VTOL aircraft propulsion system[J]. Acta Aeronautica et Astronautica Sinica,2022,43(5): 225395.1-225395.12. (in Chinese)
|
| [29] |
RAYMER D P. Aircraft design: a conceptual approach[M]. 6th edition. Reston, US: AIAA Education Series, 2018.
|
| [30] |
ROSKAM J. Airplane design: Part Ⅰ-Ⅶ[M]. 2nd edition. Lawrence, US: Design, Analysis and Research Corporation, 2003.
|
| [31] |
KHAN Y M,ROLANDO A,SALUCCI F,et al. Hybrid-electric and hydrogen powertrain modelling for airplane performance analysis and sizing[J]. Materials Science and Engineering,2022,1226: 012071.1-012071.8.
|
| [32] |
FINGER D F,DE VRIES R,VOS R,et al. Cross-validation of hybrid-electric aircraft sizing methods[J]. Journal of Aircraft,2022,59(3): 742-760. doi: 10.2514/1.C035907
|
| [33] |
李立,白俊强,刘超宇. 一种电动飞机概念方案的参数设计方法[J]. 航空动力学报,2022,37(12): 2749-2761.
LI Li,BAI Junqiang,LIU Chaoyu. A sizing method of all-electric aircraft for conceptual design[J]. Journal of Aerospace Power ,2022,37(12): 2749-2761. (in Chinese)
|
| [34] |
SWANNET K. Optimal control and energy management for hybrid aircraft[D]. Delft, Nederland: Delft University of Technology, 2022
|
| [35] |
PIPISTREL. Panthera hybrid technical data[EB/OL]. [2022-11-15].https://www.pipistrel-aircraft.com/aircraft/cruising/panthera/#tab-id-3.
|
DownLoad:
