发动机和尾喷管匹配引起的跨音振动
TRANSONIC VIBRATION INDUCED BY MISMATCHING BETWEEN ENGINE AND THRUST NOZZLE
-
摘要: 本文论述某机在试飞中,飞行状态为H=3000~4000m,Ma=0.82~0.96范围内出现跨音速振动。通过多种途径,寻找“涡”存在的部位,并且为进一步揭示振源的本质,而进行飞机模型吹风和尾喷口模型气流脉动试验,终于找到了气流脉动的原因。最后,采取改装机尾罩,通过试飞实践,排除这一振动,使飞机顺利地通过跨音速试飞。Abstract: The transonic vibration occured in the flight tests of some combat aircraft at H=3000-4000m and Ma=0.82-0.96 is analyzed in this paper. For nozzle pressure ratio of about 2.9-4.6,the vibration frequency ranged from 8 to 12Hz. Some measures were taken to discover the vibration source, such as eliminating the clearance of the aircraft structure,blocking air inlet apertures in the tail sectionof the aircraft,streamline tracing with power and strapping, and model testingin wind tunnel,but all of them failed.On the basis of extensive investigation and calculations,it was decided to make simulation test of the ejector nozzles with increased secondary flow rate or with the nozzle shroud apertured for third flow. Finally it was found out that the transonic vibration was induced by mismatching of engine with thrust nozzle. "Long skirt", "short skirt"and tail shroud with the apertures cotrolled by spring loaded differential pressure valves were tested in the flight tests. During 18 flights,the number of the differential pressure valves increased from 10 to 16,in consequence the vibration reduced to 0.1g or below,and the aircraft passed smoothly through the transonic range.
点击查看大图
计量
- 文章访问数: 1455
- HTML浏览量: 2
- PDF量: 382
- 被引次数: 0