低速条件下压气机静叶栅中弯叶片对变攻角性能影响的数值分析

基金项目: 国家自然科学基金资助(50236020)

Numerical Investigation of the Effects of Bowed Compressor Stator Vanes on Variable Incidence Performance at Low Speed

Academy of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China

摘要: 使用数值计算的方法对某型压气级静叶栅的直叶片与弯叶片变攻角特性进行了对比研究,结果发现弯叶片对正攻角下的流场特性有明显的影响。由于端区扩压因子的减小和近端区吸力面一侧的密流的增加,所以弯叶片能够消除或推迟在大正攻角下近吸力面角区分离的产生。弯叶片也因此可以扩大叶栅稳定工况范围,分析结果表明在某一弯角(20°)时,达到最大,临界攻角为16°。
- 航空、航天推进系统 /
- 低速 /
- 攻角 /
- 压气机静叶 /
- 弯叶片 /
- 临界攻角 /
- 数值分析
Abstract: The effects of the compressor bowed stator vanes on variable incidence characteristics were studied with the method of CFD.It was found that bowed vane had strong impact on flow field under positive incidence.Due to the decrease of diffusion factor near the end-wall and the augmentation of density mass flow close to the suction surface,the bowed blade eliminates or defers the separation formation near suction surface under high positive incidence and weakens the expanding of the separation region.There fore,bowed blade is able to enlarge the operation range of the stator vane.The results show the bowed blade with bow angle of 20° has maximal operation range with critical incidence of 16°.
- aerospace propulsion system /
- low mach number /
- incidence /
- compressor stator /
- bowed vane /
- critical incidence /
- numerical analysis

[1]	郑严,袁宁,王仲奇.采用弯扭导向器改型对涡轮级提高发动机性能的三维粘性流场的数值研究[J].航空动力学报,2001,16(2):153～157.ZHENG Yan,YUAN Ning,WANG Zhongqi.3-D Viscid Flow Numerical Research of Improving Aero-Engine Performance with Twisted and Bowed Turbine Guide Blades[J].Journal of Aerospace Power,2001,16(2):153～157.
[2]	Wisler D C,Bauer R C,Okiishi T H.Secondary Flow Turbulent Diffusion and Mixing in Axial Flow Compressors[R].ASME Paper 87-Gt-16,1987.
[3]	Breugelmans F A H,Carels Y,Demuth M.Influence of Dihedral on the Secondary Flow in a Two-Dimension Compressor Cascade[J].ASME Journal of Engineering for Gas Turbines and Power,106:578～ 584.
[4]	Shang E,Wang Z Q,Su J X.The Experimental Investigations on Compressor Cascades with Leaned and Curved Blades[R].ASME Paper No.93-Gt-50.
[5]	苏杰先,王仲奇.弯扭叶片动力学--回顾与展望[R].中国工程热物理学会,982033.
[6]	Chorin A J.A Numerical Method for Solving Incompressible Viscous Flow Problems[J].J.of Comput.Phys.,1967,2:12～26.