水平盘旋下裂纹转子的非线性响应

基金项目: 航空科学基金资助(03C53016)

Study of nonlinear response of cracked Jeffcott rotor in hovering state

Institute of Vibration Engineering, School of Mechanics Civil Engineering and Architecture, Northwestern Polytechnical University, Xi'an 710072, China

摘要: 研究了裂纹转子在平飞和水平盘旋状态下的非线性响应, 建立了水平盘旋下裂纹转子的数学模型, 推导了转子运动方程.由结果发现:响应进入混沌的道路有拟周期环面破裂、周期3运动失稳和阵发性混沌进入混沌3条.水平盘旋一般会对系统的非线性响应起到抑制作用, 但是系统响应的振幅明显增大, 因此增大了转轴发生断裂和转子碰摩的可能性;并且, 水平盘旋会激起转子摆振临界转速分频附近的非线性振动.
- 航空、航天推进系统 /
- 转子 /
- 水平盘旋 /
- 非线性 /
- 裂纹
Abstract: The nonlinear response of crack Jeffcott rotor in leveling and hovering state was studied,while a mathematical model of crack Jeffcott rotor in hovering state was set up,and the corresponding motion equation was derived.The results show that,there are three ways leading to chaos,which are quasi-periodic bifurcation,intermittence bifurcation and instability period-3 motion to chaos.Generally speaking,the hover can depress the nonlinear response of system,but increase considerably the amplitude of system response,thus creating a bigger possibility of axis crack and rotor collision.And,the hover will also lead to nonlinear response near the fraction frequency of swing critical speed.
- aerospace propulsion system /
- rotor /
- hover /
- nonlinear /
- crack

[1]	White J L,Heidari M A,Yantis T F.Study of engine excited non-linear vibra-acoustics in commercial airplanes[J].Proceedings of the International Modal Analysis Conference-IMAC,1997,2:1503-1508.
[2]	Ananthan S,Leishman J G.Helicopter rotor wake dynamics during simulated tactical maneuvers[J].Annual Forum Proceedings-American Helicopter Society,2004,1:949-980.
[3]	徐敏,廖明夫,刘启洲.机动飞行条件下双盘悬臂转子的振动特性[J].航空动力学报,2002,17(1):105-109.XU Min,LIAO Mingfu,LIU Qizhou.The vibration performance of the double-disk cantilever rotor in flight mission[J].Journal of Aerospace Power,2002,17(1):105-109.
[4]	杨永锋,任兴民,秦卫阳.一种描述非线性动力学响应的新方法[J].中国机械工程,2005,16(16):1468-1470.YANG Yongfeng,REN Xingmin,QIN Weiyang.Description nonlinear responses using peak-to-peak values[J].China Mechanical Engineering,2005,16(16):1468-1470.
[5]	杨永锋.机动飞行下裂纹转子的非线性特性研究[D].西安:西北工业大学,2006.YANG Yongfeng.Study of the nonlinear dynamic characteristic of cracked rotor in maneuver flight[D].Xi'an:Northwestern Polytechnical University,2006.
[6]	Gasch R,Person M,Weitz B.Dynamic behaviour of the Laval rotor with a cracked hollow shaft-a comparison of crack models[A].Proceedings of the 4th Internation Conference on Vibration in Rotating Machinery[C].Great Britan:Mechanieal Engineering Publications Limited,1988:463-472.