一种识别单盘柔性转子不平衡的新方法

黄金平; 任兴民

一种识别单盘柔性转子不平衡的新方法

西北工业大学振动工程研究所, 西安 710072

计量
- 文章访问数: 1468
- HTML浏览量: 142
- PDF量: 416
- 被引次数: 0
出版历程
- 收稿日期: 2007-01-04
- 修回日期: 2007-04-09
- 刊出日期: 2008-02-28

A novel method of identifying the imbalance of flexible rotor with one disc

Institute of Vibration Engineering, Northwestern Polytechnical University, Xi'an 710072, China

摘要

摘要: 基于柔性转子瞬态响应和反向传播神经网络理论,提出了一种识别单盘柔性转子不平衡的新方法.通过转子的理论模型建立识别转子不平衡方位角的BP神经网络,在此基础上只需两次加速启动过程就可完成对转子不平衡的识别.首先通过BP神经网络和第一次启动过程的瞬态响应数据,识别出转子不平衡的方位角;然后再通过一次加试重启动过程,利用瞬态挠度的幅值与不平衡大小之间的线性关系,识别出不平衡的大小.实验结果证明了该方法的有效性.
- 航空、航天推进系统 /
- 转子 /
- 瞬态响应 /
- BP神经网络 /
- 不平衡识别
Abstract: Based on the transient response of a flexible rotor and the fundamental theory of back propagation(BP) neural network,a novel method for imbalance identification of flexible rotor with one disc was presented.A BPneural network identifying imbalance angle of rotor was established by using the theoretical model of the rotor,thus enabling imbalance identification of rotor through only two accelerations.Firstly,the imbalance angle was identified by BPneural network and the transient response of the first acceleration;secondly,the magnitude of the imbalance was acquired through a second acceleration using the linear relationship between the magnitude of transient flexibility and the imbalance.The experimental result verifies the effectiveness of this imbalance identification method.
- aerospace propulsion system /
- rotors /
- transient response /
- back propagation(BP) neural network /
- imbalance identification

HTML

参考文献(8)

[1]	邱海,屈梁生,张海军,等.神经网络在转子动平衡中应用的几个关键问题[J].机械工程学报,2001,37(1):88-91.QIU Hai,QU Liangsheng,ZHANG Haijun,et al.Some key problems of the neural network applied in rotor balancing[J].Chinese Journal of Mechanical Engineering,2001,37(1):88-91.
[2]	SUN Shouqun,ZHAO Sanxing,ZHANG Wei.A study on turbo-rotor multi-fault diagnosis based on a neural network[J].International Journal of Plant Engineering and Management,2003,8(2):80-87.
[3]	Vyas N S,Satishkumar D.Artificial neural network design for fault identification in a rotor-bearing system[J].Mechanism and Machine Theory,2001,36(2):157-175.
[4]	Kowalski C T,Orlowska-Kowalska T.Neural networks application for induction motor faults diagnosis[J].Mathematies and Computers in Simulation,2003,63(3-5):435-448.
[5]	Hagan M T,Demuth H B,Beale M.Neural network design[M].Beijing:China Machine Press,2002.
[6]	Kalkat M,Yildirim S,Uzmay I.Design of artificial neural networks for rotor dynamics analysis of rotating machine systems[J].Mechatronics,2005,15(5):573-588.
[7]	顾家柳,丁奎元,刘启洲,等.转子动力学[M].北京:国防工业出版社,1985.GU Jialiu,DING Kuiyuan,LIU Qizhou,et al.Rotordynamics[M].Beijing:National Defence Press,1985.
[8]	EI-Shafei A,EI-Kabbany A S,Younan A A.Rotor balancing without trial weights[J].ASME Journal of Engineering for Gas Turbines and Power,2004,126:604-609.