气体润滑轴承-转子系统非线性动力学特征的实验

陈策; 杨金福; 聂超群

气体润滑轴承-转子系统非线性动力学特征的实验

陈策^1,2,3,
杨金福¹,
聂超群¹

1.
中国科学院工程热物理研究所, 北京 100190
2.
中国科学院研究生院, 北京 100039
3.
北京航空工程技术研究中心, 北京 100076

计量
- 文章访问数: 1609
- HTML浏览量: 269
- PDF量: 473
- 被引次数: 0
出版历程
- 收稿日期: 2007-07-27
- 修回日期: 2007-11-10
- 刊出日期: 2008-08-28

Experimental research on nonlinear dynamic characteristic of gas lubrication bearings and high speed rotors

1.
Institute of Engineering Thermophysics, Chinese Academy of Sciences, Beijing 100190, China
2.
Graduate School, Chinese Academy of Sciences, Beijing 100039, China
3.
Beijing Aeronautical Technique Research Center, Beijing 100076, China

摘要

摘要: 对高速气体润滑轴承转子系统进行了稳定性试验研究.通过轴心轨迹、频率耦合三维图、频谱和分叉图,分析了系统非线性行为特征.实验证明气体润滑轴承-转子系统中的气膜涡动是系统非线性失稳的主要原因,气膜涡动导致的倍周期分叉是系统进入混沌振动的必由途径.通过调整系统固有频率和气膜润滑涡动频率之间的耦合关系,使得失稳转速远离设计转速;以及利用试验中所证实的混沌"有界"性质,有效的控制振幅,将是提高转子-轴承系统非线性稳定性的新途径.
- 气体润滑轴承 /
- 非线性动力学特性 /
- 高速转子 /
- 稳定性
Abstract: A stability experiment on high speed rotor and gas lubrication bearings was presented in this paper.Based on shaft center orbits,frequency coupling 3-D plot,frequency spectrum and bifurcation plot,the nonlinear characteristics of rotor bearing system were analyzed.The experiment proved that,gas whirl in gas bearing and rotor system was a major contributing factor to nonlinear instability.Double periodic bifurcation caused by gas whirl was an inevitable path to chaos vibration.The instability rotational speed will vary a lot from design speed by modulation of the coupling relationship between system's inherent frequency and gas whirl frequency,meanwhile effective control of chaos vibration based on bounded ness of chaos is a new method to improve nonlinear stability of rotor and bearings.
- gas lubrication bearings /
- nonlinear dynamics /
- high speed rotor /
- stability

HTML

参考文献(4)

[1]	张正松,沐华平.油膜失稳涡动极限环特性的Hopf分叉分析法[J].清华大学学报,1996,36(7):123-126.ZHANG Zhengsong,MU Huaping.Hopf bifurcation analysis on oil whirl instability limit cycles[J].Transaction of TsingHua University,1996,36(7):123-126.(in Chinese)
[2]	高普云.非线性动力学-分叉、混沌和孤立子[M].长沙:国防科技大学出版社,2005.GAO Puyun.Nonlinear dynamics-bifurcation,chaos and soliton[M].Changsha,National Defense University of Science and Technology Press,2005.(in Chinese)
[3]	杨金福,杨昆,于达仁,等.滑动轴承非线性油膜力研究[J].振动工程学报,2005,18(1):118-123.YANG Jinfu,YANG Kun,YU Daren,et al.Research on sliding bearings nonlinear oil force[J].Journal of vibration engineering,2005 18(1),118-123.(in Chinese)
[4]	张琪昌,王洪礼.分叉与混沌理论及应用[M].天津:天津大学出版社,2004:172.ZHANG Qichang,WANG Hongli.Bifurcation and chaos:theory and application[M].Tianjin:Tianjin University Press,2004:172.(in Chinese)