同轴式气-气喷注器混合场影响因素流动显示研究

金平; 杜正刚; 杨立军; 蔡国飙

同轴式气-气喷注器混合场影响因素流动显示研究

北京航空航天大学宇航学院,北京 100191

基金项目: 国家高技术研究发展计划

计量
- 文章访问数: 1649
- HTML浏览量: 97
- PDF量: 23
- 被引次数: 0
出版历程
- 收稿日期: 2009-12-02
- 修回日期: 2010-06-12
- 刊出日期: 2011-03-28

Research on flow visualization of coaxial gas-gas injector mixing flowfield

School of Astronautics, Beijing University of Aeronautics and Astronautics,Beijing 100191,China

摘要

摘要: 为了深入理解同轴气-气喷注器气流混合机理,利用粒子图像测速仪(PIV)系统对同轴直流式和同轴离心式气-气喷注器开展了流动显示实验,研究了喷注器关键设计参数对气流混合扩散过程的影响规律.实验结果表明:对于同轴直流式喷注器,氧/氢动量比决定着气流接触面上卷吸作用的大小,动量比越大,卷吸作用越强,混合效果越好;对于同轴离心式喷注器,气流的旋度控制着气流的混合过程,旋度越大,混合效果越好.可以通过减小外环喷注压降或者给中心喷孔一定的缩进距离来增大旋度,增强旋流作用,加强气流的混合.
- 同轴直流式气-气喷注器 /
- 同轴离心式气-气喷注器 /
- 粒子图像测速仪 /
- 混合场 /
- 动量比
Abstract: To pursue the proper design criteria for gas-gas injector,the flow visualization technology with particle image velocimetry(PIV) system was adopted to investigate the mixing mechanism.The coaxial shear and swirl configurations were selected.The results show that the momentum ratio of oxygen to hydrogen prevails in the mixing process of coaxial shear injector,while the swirl numbers dominate the mixing part of coaxial swirl injector.Good mixing was gained at high momentum ratio and high swirl numbers.For the designer,the combination of high annular pressure drop and low center pressure drop is recommended for the coaxial shear injector,and the combination of low annular pressure drop and proper recess length of center post recommended for swirl injector.
- coaxial shear gas-gas injector /
- coaxial swirl gas-gas injector /

HTML

参考文献(12)

[1]	Davis J A,Campbell R L.Advantages of a full-flow staged combustion cycle engine system .AIAA 97-3318,1997.
[2]	Farhangi S,Yu T,Rojas L,et al.Gas-gas injector technology for full flow combustion cycle application .AIAA 99-2757,1999.
[3]	Calhoon D F,Ito J I,Kors D L.Investigation of gaseous propellant combustion and associated injector/chamber design guidelines .NAS 3-14379,1973.
[4]	金平,杜正刚,杨立军,等.气-气喷注器混合场流动显示[J].航空动力学报,2011,26(1):210-216. JIN Ping,DU Zhenggang,YANG Lijun,et al.Flow visualization of gas-gas injector mixing flowfield[J].Journal of Aerospace Power,2011,26(1):210-216.(in Chinese)
[5]	代钦,魏润杰,黄湛,等.超音速喷流DPIV瞬时速度场实验测量[J].北京航空航天大学学报,2001,27(6):665-669. DAI Qin,WEI Runjie,HUANG Zhan,et al.Experimental study of supersonic jet flow using DPIV[J].Journal of Beijing University of Aeronautics and Astronautics,2001,27(6):665-669.(in Chinese)
[6]	魏润杰,申功炘.DPIV系统研制及其应用[J].流体力学实验与测量,2003,17(2):88-92. WEI Runjie,SHEN Gongxin.The research of DPIV system and its application[J].Experiments and Measurements in Fluid Mechanics,2003,17(2):88-92.(in Chinese)
[7]	余常昭.紊动射流[M].北京:高等教育出版社,1993.
[8]	平浚.射流理论基础及应用[M].北京:宇航出版社,1995.
[9]	庄逢辰.液体火箭发动机喷雾燃烧的理论、模型及应用[M].长沙:国防科技大学出版社,1995.
[10]	赵承庆,姜毅.气体射流动力学[M].北京:北京理工大学出版社,1998.
[11]	Kilik E,Finstad R.A numerical study of co- and counter-swirling confined coaxial jets .AIAA-86-1722,1986.
[12]	Rajaratnam N.Turbulent jets[M].New York:Elsevier Scientific Publishing Company,1976.