旋转状态气膜换热机理的数值研究

刘宁; 孙纪宁

旋转状态气膜换热机理的数值研究

刘宁,
孙纪宁

北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室,北京100191

计量
- 文章访问数: 1738
- HTML浏览量: 46
- PDF量: 18
- 被引次数: 0
出版历程
- 收稿日期: 2010-03-11
- 修回日期: 2010-06-26
- 刊出日期: 2011-04-28

Numerical simulation of heat transfer physics of film cooling under rotating conditions

National Key Laboratory of Science and Technology on Aero-Engine Aero-thermodynamics, School of Jet Propulsion,Beijing University of Aeronautics and Astronautics, Beijing 100191,China

摘要

摘要: 大涡模拟研究了旋转对单孔平板气膜冷却的影响,气膜出流的雷诺数为2600,吹风比为0.5,计算了静止和旋转数为0.02两种状态的流动和换热,从湍流结构演化的角度讨论了旋转状态气膜换热的机理.结果表明:①发卡涡是决定气膜换热的主要湍流结构,旋转状态发卡涡的形状和运动规律主要受哥氏力的影响;②气膜在哥氏力作用下向高半径方向偏移,弱化了射流前缘与主流的剪切和掺混,使气膜保持较低温度;③气膜的侧向速度诱发垂直向下的哥氏力,压制射流贴附壁面,并降低对转涡对的强度,减少了对主流的卷吸,增强了气膜的保护效果.
- 气膜冷却 /
- 大涡模拟 /
- 旋转状态 /
- 哥氏力 /
- 湍流结构
Abstract: Large eddy simulation was used to investigate the effect of rotation on film cooling over flat plate with single hole.The Reynolds number at the jet exit was 2600,and the blowing ratio was 0.5.The flow and heat transfer without rotation and with rotating number of 0.02 were calculated,and the heat transfer mechanics under rotating condition was analyzed through the evolvement of turbulence structure.It was found that hairpin structure determined the heat transfer of film cooling,and the shape and trajectory of hairpin structure was mainly affected by Coriolis force under rotating condition.The film was driven towards high radius side by spanwise Coriolis force,resulting in less mixing between main flow and jet and maintaining low temperature of the film.The Coriolis force normal to the wall reinforced the film attachment and reduced the strength of counter rotating vortex pair,leading to less entrainment of mainflow and better coverage of film.
- film cooling /
- large eddy simulation /
- rotation condition /
- Coriolis force /
- turbulence structure

HTML

参考文献(16)

[1]	葛绍岩,刘登瀛,徐靖中,等.气膜冷却[M].北京:科学出版社,1985.
[2]	Han J C,Dutta S,Ekkad S.Gas turbine heat transfer and cooling technology[M].London:Taylor & Francis,2000.
[3]	Dunn M G.Convective heat transfer and aerodynamics in axial flow turbines[J].Journal of Turbomachinery,2001,123(4):637-686.
[4]	Dring R P,Blair M F,Joslyn H D.An experimental investigation of film cooling on a turbine rotor blade[J].Journal of Engineering for Power,1980,102(1):81-87.
[5]	Takeishi K,Aoki S,Sato T,et al.Film cooling on a gas turbine rotor blade[J].Journal of Turbomachinery,1992,114(4):828-834.
[6]	Abhari R S,Epstein A H.An experimental study of film cooling in a rotating transonic turbine[J].Journal of Turbomachinery,1994,116(1):63-70.
[7]	杨晓军.旋转状态下气膜出流沿曲面与主流掺混机理的研究 .北京:北京航空航天大学,2007. YANG Xiaojun.Study on the film cooling over the curved walls under rotating frame .Beijing:Beijing University of Aeronautics and Astronautics,2007.(in Chinese)
[8]	Acharya S.Large eddy simulations and turbulence modeling for film cooling .NASA/CR-1999-209310,1999.
[9]	Guo X,Schrder W,Meinke M.Large-eddy simulations of film cooling flows[J].Computers & Fluids,2006,36(6):587-606.
[10]	Rozati A,Tafti D K.Large-eddy simulations of leading edge film cooling:analysis of flow structures,effectiveness,and heat transfer coefficient[J].International Journal of Heat and Fluid Flow,2008,29(1):1-17.
[11]	Tyagi M,Acharya S.Large eddy simulation of film cooling flow from an inclined cylindrical jet[J].Journal of Turbomachinery,2003,125(4):734-742.
[12]	Liu K L,Pletcher R H.Large eddy simulation of discrete-hole film cooling in a flat plate turbulent boundary layer .AIAA 2005-4944,2005.
[13]	Niceno B.An unstructured parallel algorithm for large eddy and conjugate heat transfer simulations .Delft:Delft University,2001.
[14]	Mendez S,Nicoud F.Large-eddy simulation of a bi-periodic turbulent flow with effusion[J].Journal of Fluid Mechanics,2008,598:27-65.
[15]	Liu N,Hanjalic K,Borello D,et al.Large-eddy simulation of periodic discrete-hole effusion without and with rotation .Graz:8th European Conference on Turbomachinery,Fluid Dynamics and Thermodynamics,2009.
[16]	Dubief Y,Delcayre F.On coherent-vortex identification in turbulence[J].Journal of Turbulence,2000,1(1):011(1-22).