进气畸变与旋转失速诱导叶片振动的相关性分析

杜建建; 李舜酩; 方立成

进气畸变与旋转失速诱导叶片振动的相关性分析

基金项目: 国家自然科学基金(50675099)

计量
- 文章访问数: 1645
- HTML浏览量: 155
- PDF量: 51
- 被引次数: 0
出版历程
- 收稿日期: 2010-12-11
- 修回日期: 2011-06-10
- 刊出日期: 2011-11-28

Correlation analysis of blade vibration induced by inlet distortion and rotating stall

摘要

摘要: 为了定量地分析进气畸变与旋转失速两种气动载荷之间以及两者单独激励下叶片位移响应之间的相关程度,基于双级低速轴流压气机试验器上进行的进气畸变试验与旋转失速试验所得的流场数据,对叶片在两者单独激励下的振动特性进行仿真计算,并从统计学的角度对变量之间的相关性进行分析.结果表明:两种流场压力数据之间相关性极高,说明两者共享的特征较多;节点位移响应之间的相关程度低于两种压力载荷之间的相关程度;同一叶型截面上节点位移响应之间的相关系数曲线大致成不对称的V字型;沿叶身截面从叶根至叶尖节点位移响应之间的相关系数逐渐降低,主要与边界条件有关.
- 相关分析 /
- 叶片振动 /
- 进气畸变 /
- 旋转失速 /
- 数值仿真
Abstract: To analyze correlation degree between inlet distortion and rotating stall quantitatively,as well as blade displacement responses induced by them,blade vibration characteristics were simulated under inlet distortion or rotating stall by software ANSYS based on measurement data obtained from two stage low speed axial compressor,and correlation analysis between variables was made with statistics theories.The results indicate:two flow pressure data are highly related,and many characteristics are shared by them.Correlation degree between displacement responses is lower than that between inlet distortion and rotating stall.Correlation coefficient curve between displacement responses of the same section is of roughly asymmetrical V shape.Correlation coefficient between displacement responses of blade body from root to tip decreases gradually as it is mainly related to boundary conditions.
- correlation analysis /
- blade vibration /
- inlet distortion /
- rotating stall /

HTML

参考文献(12)

[1]	Yao J X,Gorrell S E,Wadia A R.A time-accurate CFD analysis of inlet distortion induced swirl in multistage fans .Cincinnati,OH:43rd AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit,2007.
[2]	Danforth C E. Distortion-induced vibration in fan and compressor blade[J].Journal of Aircraft,1975,12(4):216- 225.
[3]	欧阳绍泽.航空发动机第一级压气机叶片对进气气流畸变的振动响应分析和计算[J].西北工业大学学报,1984,2(1): 115-129. OUYANG Shaoze.Analysis and calculation of vibration response induced by inflow distortion in the first-stage compressor blading of turbo-engine[J].Journal of Northwestern Polytechnical University,1984,2(1):115-129.(in Chinese)
[4]	陈群,杜少辉,李文兰.进气畸变对某压气机一级叶片振动的影响[J].航空动力学报,1990,5(4):339-342. CHEN Qun,DU Shaohui,LI Wenlan.Effect of inlet distortion on blade vibration and inlet distortion tolerance[J].Journal of Aerospace Power,1990,5(4):339-342.(in Chinese)
[5]	Rabe D,Bolcs A,Russler P.Influence of inlet distortion on transonic compressor blade loading .San Diego,CA:31st AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit,1995.
[6]	杜少辉.航空发动机进气畸变诱导叶片振动的研究[J].航空发动机,2003,29(3):30-34. DU Shaohui.Investigation of blade vibration induced by inlet distortion in an aero-engine[J].Aeroengine,2003,29(3):30-34.(in Chinese)
[7]	Engeda A.Rotating stall in centrifugal compressor and its effect on inducing vibration .Indianapolis,IN:30th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit,1994.
[8]	戚先萍,杨秉玉,胡璧刚.压气机旋转失速对叶片振动影响的实验研究[J].燃气涡轮试验与研究,1998,11(2):24- 26. QI Xianping,YANG Bingyu,HU Bigang.Experimental investigation of the influence of compressor rotating stall on vibration of blades[J].Gas Turbine Experiment and Research, 1998,11(2):24-26.(in Chinese)
[9]	王梅,江和甫,吕文林.在尾流激振情况下叶片振动应力预估技术[J].航空动力学报,2007,22(4):608-613. WANG Mei,JIANG Hefu,LV Wenlin.Method to predict the blade vibration stress induced by wake flow[J].Journal of Aerospace Power,2007,22(4):608-613.(in Chinese)
[10]	Falk E A,Darbe R P.Investigation of 2D IGV-rotor interactions in a F109 turbofan engine .AIAA 2003-4981, 2003.
[11]	程荣辉.轴流压气机设计技术的发展[J].燃气涡轮试验与研究,2004,17(2):1-8. CHENG Ronghui.Development of design technology for axial compressor[J].Gas Turbine Experiment and Research, 2004,17(2):1-8.(in Chinese)
[12]	高晋占.微弱信号检测[M].北京:清华大学出版社,2004.