航空发动机滚动轴承-双转子系统动态特性分析

邓四二; 付金辉; 王燕霜; 杨海生

航空发动机滚动轴承-双转子系统动态特性分析

河南科技大学机电工程学院,河南洛阳 471003

基金项目: 国家“十一五”科技攻关项目(JPPT-115-189); 国家“十二五”科技攻关项目(JPPT-ZCGX1-1); 河南科技大学博士基金(09001398)

计量
- 文章访问数: 1615
- HTML浏览量: 147
- PDF量: 1308
- 被引次数: 0
出版历程
- 收稿日期: 2012-01-12
- 刊出日期: 2013-01-28

Analysis on dynamic characteristics of aero-engine rolling bearing/dual-rotor system

College of Mechatronics Engineering, Henan University of Science and Technology,Luoyang Henan 471003,China

摘要

摘要: 在滚动轴承动力学和转子动力学分析基础上,建立了含滚动轴承动力学与转子动力学耦合以及高、低压转子间耦合的滚动轴承-双转子系统动力学方程,采用精细积分法和预估-校正Adams-Bashforth-Moulton多步法相结合的算法,对航空发动机滚动轴承-双转子系统非线性动力学方程进行求解,并对滚动轴承结构参数与转子动态特性的关系进行了理论分析.分析结果表明:①中介轴承径向游隙较小时转子系统振动量较小且转子运行较平稳,但中介轴承保持架打滑率会有所提高,应合理选取中介轴承的径向游隙值;中介轴承滚子数量对转子运转稳定性有较大影响,减小中介轴承滚子数量可降低保持架打滑率,但转子系统的振动量会增大;②支承轴承内、外沟曲率半径系数及径向游隙较小时转子系统的振动量较小,转子运转较稳定;支承轴承滚动体数量对转子运转稳定性有较大影响,滚动体数量增多有利于转子系统运行的平稳性.
- 滚动轴承 /
- 双转子系统 /
- 动力学特性 /
- 耦合 /
- 稳定性
Abstract: The dynamic model of dual-rotor coupling system which included rolling bearing dynamics and rotor dynamics was established.Fine integral method and predict-correct Adams-Bashforth-Moulton multi-step method were used to solve the nonlinear dynamic equations of dual-rotor system.Then the influences of bearing structural parameters on dynamic response of rotors were studied.The result shows:(1)the displacement of rotors can be decreased and the stability of rotors can be improved by reducing radical clearance of inter-shaft bearing,but the slide ratio of cage would increase when the radial clearance decreases,so the radial clearance should be selected properly;the slide ratio of cage would decrease and the displacement of rotors would increase when the rollers of inter-shaft bearing are reduced;(2)the displacement and stability of rotors can be optimized when the groove curvature radius coefficients of rings and radial clearance of supporting bearings are decreased,and the stability of rotor would be improved when the rolling elements of bearings are increased.
- rolling bearing /
- dual-rotor system /
- dynamic characteristics /
- coupling /
- stability

HTML

参考文献(15)

[1]	周海仑,陈果.航空发动机双转子-滚动轴承-机匣耦合系统动力学分析[J].航空动力学报,2009,24(6):1284-1291. ZHOU Hailun,CHEN Guo.Dynamic response analysis of dual rotor-ball bearing-stator coupling system for aero-engine[J].Journal of Aerospace Power,2009,24(6):1284-1291.(in Chinese)
[2]	HU Qinghua,DENG Sier,TENG Hongfei.A 5-DOF model for aeroengine spindle dual-rotor system analysis[J].Chinese Journal of Aeronautics,2011,24(2):224-234.
[3]	Gupta K D,Gupta K,Athre K.Unbalance response of a dual rotor system:theory and experiment[J].Journal of Vibration and Acoustics,1993,115(4):427-435.
[4]	Chiang H W D,Hsu C N,Tu S H.Rotor-bearing analysis for turbo machinery single-and dual-rotor system[J].Journal of Propulsion and Power,2004,20(6):1096-1104.
[5]	Chiang H W D,Hsu C N,Jeng W,et al.Turbo machinery dual rotor-bearing system analysis .ASME Paper GT-2002-30315,2002.
[6]	罗贵火,胡绚,杨喜关.反向旋转双转子系统非线性分析[J].振动工程学报,2009,22(3):268-273. LUO Guihuo,HU Xuan,YANG Xiguan.Non-linear analysis of counter-rotating dual-rotor's system[J].Journal of Vibration Engineering,2009,22(3):268-273.(in Chinese)
[7]	BAI Changqing,XU Qingyu.Dynamic model of ball bearings with internal clearance and waviness[J].Journal of Sound and Vibration,2006,24(4):23-48.
[8]	崔立,王黎钦,郑德志,等.航空发动机高速滚子轴承动态特性分析[J].航空学报,2008,29(2):492-498. CUI Li,WANG Liqin,ZHENG Dezhi,et al.Analysis on dynamic characteristics of aero-engine high-speed roller bearings[J].Acta Aeronautica et Astronautica Sinica,2009,29(2):492-498.(in Chinese)
[9]	Karthik K,Nataraj C.Nonlinear modeling and analysis of a rolling element bearing with clearance[J].Nonlinear Science Number Simulation,2011,16(10):4134-4145.
[10]	邓四二,贺凤祥,杨海生,等.航空发动机双转子-滚动轴承-耦合系统的动力特性分析[J].航空动力学报,2010,25(10):1-10. DENG Sier,HE Fengxiang,YANG Haisheng.Analysis on dynamic characteristics of a dual rotor-rolling bearing coupling system for aero-engine[J].Journal of Aerospace Power,2010,25(10):1-10.(in Chinese)
[11]	邓四二,贾群义.滚动轴承设计原理[M].北京:中国标准出版社,2008:236-239.
[12]	Harris T A,Kotzalas M N.滚动轴承分析:第2卷[M].5版.罗继伟,马伟,译.北京:机械工业出版社,2010:8-13.
[13]	Chang J.Coupling effect of flexible geared rotor on quick-return mechanism undergoing three-dimensional vibration[J].Journal of Sound and Vibration,2007,300(1/2):139-159.
[14]	Villa C,Sinou J J,Thouverez F.Stability and vibration analysis of a complex flexible rotor bearing system[J].Nonlinear Science and Numerical Simulation,2008,13(4):804-821.
[15]	陈立平,张云清,任卫群,等.机械系统动力学分析及ADAMS 应用教程[M].北京:清华大学出版社,2005:259-272.