错频对叶片的气动弹性稳定性影响

郑赟; 王静

错频对叶片的气动弹性稳定性影响

郑赟,
王静

北京航空航天大学能源与动力工程学院, 北京 100191

计量
- 文章访问数: 2326
- HTML浏览量: 437
- PDF量: 1329
- 被引次数: 0
出版历程
- 收稿日期: 2012-05-23
- 刊出日期: 2013-05-28

Influence of frequency mistuning on aeroelastic stability of blade

School of Energy and Power Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China

摘要

摘要: 采用求解动网格下的非定常可压缩Navier-Stokes方程模拟了振荡叶片下的气动弹性问题,研究了叶片的频率错频对叶片气动弹性稳定性的影响.通过数值模拟平面叶栅的气动弹性第10标准算例,验证了气动弹性的数值模拟方法,计算了不同叶片间相位角和折合频率下的气动阻尼系数,研究了叶片振动频率改变对叶片气动弹性稳定性的影响.计算结果说明:频率错频是提高气动弹性稳定性的有效方法,其主要作用是减小叶片间振动的耦合效应和叶片间相位角的影响,并且随着错频量增大叶片稳定性增强;通过模拟三维环形叶栅的气动弹性第4标准算例,计算了气动阻尼系数随错频量变化的规律,验证了错频量和气动弹性稳定性增强的规律.
- 气动弹性 /
- 颤振 /
- 错频 /
- 叶片间相位角 /
- 能量法
Abstract: Aeroelastic stability of oscillating blades was simulated by solving unsteady compressible Navier-Stokes equations with dynamic deforming mesh, and the effect of frequency mistuning on aero-dynamic damping was investigated. The aeroelasticity algorithm was validated by the simulation of aeroelastic behavior of the 10th aeroelastic standard configuration. The aero-dynamic damping of the oscillating cascade was calculated with different inter-blade phase angles (IBPA) and reduced frequencies. The effects of mistuning pattern and frequency of mistuning on aero-dynamic damping and the mechanism of frequency mistuning on aeroelastic stability were studied. The results indicate that frequency mistuning is an effective method in improving aeroelastic stability and the coupling of the blade vibration and the effect of IBPA were weakened by frequency mistuning; the aeroelastic stability of blade increases with the increase of frequency mistuning. 3-D aeroelstic computation of the 4th aeroelastic standard configuration was performed to examine the effects of frequency mistuning on aeroelastic stability margin, and the laws of IBPA and aeroelastic stability increasing was validated.
- aeroelasticity /
- flutter /
- frequency mistuning /
- inter-blade phase angle(IBPA) /
- energy method

HTML

参考文献(19)

[1]	Cumpsty N A.Compressor aerodynamics[M].New York: Halsted Press,1989.
[2]	Meldahl A.Selbsterregte flügelschwingu-ngen mit einem freiheitsgrad[J].Brown Boveri Mitteilungen,1946,33(12):386-393.
[3]	Lane F.System mode shapes in the flutter of compressor blade rows[J].Journal of the Aeronautical Sciences,1956,23(1):54-66.
[4]	Strazisar A J,Wood J R,Hathaway M D.Laser anemometer measurements in a transonic axia-flow rotor.NASA Technical Paper 2879,1989.
[5]	Whitehead D S.Effect of mistuning on the vibration of turbo-machine blades induced by wakes[J].Journal of Mechanical Engineering Science,1966,8(1):15-21.
[6]	Ewins D.The effect of detuning upon the forced vibrations of bladed disks[J].Journal of Sound and Vibration,1969,9(1):65-79.
[7]	Kaza K R V,Kielb R E.Flutter and response of a mistuned cascade in incompressible flow[J].AIAA Journal,1982,20(8):120-1127.
[8]	Kielb R E,Kaza K R V.Effects of structural coupling on mistuned cascade flutter and response[J].Journal of Engineering for Gas Turbines Power,1984,106(1):17-24.
[9]	王建军,于长波,李其汉.错频叶盘结构振动模态局部化特性分析[J].航空动力学报,2009,24(4): 354-361. WANG Jianjun,YU Changbo,LI Qihan.Localization characteristics of vibratory mode for bladed disks assemblies[J].Journal of Aerospace Power,2009,24(4): 354-361.(in Chinese)
[10]	Sinha A.Reduced-order model of a bladed rotor with geometric mistuning[J].Journal of Turbomachinery,2009,131(3): 31007.1-31007.7.
[11]	Feiner D M,Griffin J.Mistuning identification of bladed disksusing a fundamental mistuning model:Part I theory[J].Journal of Turbomachinery,2004,126(1):150-158.
[12]	Castanier M P,Pierre C.Modeling and analysis of mistuned bladed disk vibration: status and emerging directions[J].Journal of Propulsion and Power,2006,22(2):384-389.
[13]	Kazawa J,Watanabe T.Numerical analysis toward active control of cascade flutter with smart structure[J].AIAA 2002-4079,2002.
[14]	Sadeghi M,Liu F.Computation of mistuning effects on cascade flutter[J].AIAA Journal,2001,39(1):22-28.
[15]	Sadeghi M,Liu F.Investigation of mistuning effects on cascade flutter using a coupled method[J].Journal of Propulsion and Power,2007,23(2):266-272.
[16]	郑赟.基于非结构网格的气动弹性数值方法研究[J].航空动力学报,2009,24(9):2069-2077. ZHENG Yun.Computational aeroelasticity with an unstructured method[J].Journal of Aerospace Power,2009,24(9):2069-2077.(in Chinese)
[17]	Bölcs A,Fransson T H.Aeroelasticity in turbomachines:comparison of theoretical and experimental results[R].Lausanne,Switzerland: Communication du Laboratoire de Thermique Appliqué et de Turbomachines,1986.
[18]	Fransson T H,Verdon J M.Updated report on "standard configurations for unsteady flow through vibrating axial-flow turbomachine-cascades"[R].Stockholm,Sweden: Royal Institute of Technology Report,1991.
[19]	Hall K C,Laurence C B.Calculatin of three dimensional unsteady floes in turbomachinery using the linearized harmonic euler equations[J].Journal of Turbomachinery,1993,115(4):800-809.