Analysis of cooling air flow field in front power compartment of tracked vehicle
-
摘要: 以某履带车辆前置动力舱为研究对象,建立了舱内冷却空气流场的物理模型与数学模型,对装备有多个散热器且入口边界条件不同的动力舱内、外部冷却空气流场进行了仿真研究,并与实车测试结果进行了对比,分析了不同车速对各散热器冷却空气质量流量的变化规律的影响.结果表明:在相同风扇转速下,随着车速由0km/h增加到70km/h,两个散热器及两个风扇的质量流量均有10%左右的变化,但是两个散热器的总质量流量基本不变.车速在0~70km/h变化时,由仿真计算和试验测试所得的各散热器和风扇的冷却空气质量流量变化率之差都小于5%.Abstract: Cooling air flow fields of front power compartment in tracked vehicle were researched,while both physical and mathematical models were built.Cooling air flow fields around inner and exterior of a power compartment equipping with several radiators with different entry boundary conditions were simulated.These studies were compared with the experimental results.The influence of vehicle speeds on change regular of cooling air mass flow of radiators was analyzed.The research shows that,under the same rotating speed of the fan,mass flows of two fans and two radiators change about 10% from 0 to 70km/h of vehicle speeds,and the total mass flow of two radiators is nearly stable.For the radiators and fans,the change rate of cooling air mass flow between the simulation and experiments are less than 5% when vehicle speeds change from 0 to 70km/h.
-
Key words:
- front engine compartment /
- air flow field /
- vehicle speed /
- radiator /
- fan
-
[1] 李佑长, 吕林, 戴湘利, 等.某四缸柴油机冷却水流动的试验研究[J].武汉理工大学学报:交通科学与工程版, 2006, 30(5):793-795. LI Youchang, LÜ Lin, DAI Xiangli, et al.Experimental study of cooling water flow for 4-cylinder diesel engine[J].Journal of Wuhan University of Technology:Transportation Science and Engineering, 2006, 30(5):793-795.(in Chinese) [2] 王义春, 杨英俊, 谷中丽.混合动力车辆冷却系统优化设计[J].北京理工大学学报, 2004, 24(1):44-47. WANG Yichun, YANG Yingjun, GU Zhongli.Optimized design of the cooling system for a hybrid electric vehicle[J].Transactions of Beijing Institute of Technology, 2004, 24(1):44-47.(in Chinese) [3] 袁侠义, 谷正气, 杨易, 等.汽车发动机舱的数值仿真研究[J].汽车工程, 2009, 31(9):843-847. YUAN Xiayi, GU Zhengqi, YANG Yi, et al.Numerical simulation on vehicle under hood cooling[J].Automotive Engineering, 2009, 31(9):843-847.(in Chinese) [4] 徐晓明, 赵又群.某型轿车内流场的仿真分析[J].航空动力学报, 2009, 24(12):2780-2783. XU Xiaoming, ZHAO Youqun.Simulation analysis of a car interior flow field[J].Journal of Aerospace Power, 2009, 24(12):2780-2783.(in Chinese) [5] 徐晓明, 赵又群.微型纯电动汽车动力舱风冷散热研究[J].航空动力学报, 2012, 27(7):1532-1536. XU Xiaoming, ZHAO Youqun.Research on wind cooling disperse heat of micro electric vehicle power cabin[J].Journal of Aerospace Power, 2012, 27(7):1532-1536.(in Chinese) [6] 徐晓明, 赵又群.汽车方舱空调系统的仿真分析[J].哈尔滨工业大学学报, 2012, 44(3):92-95. XU Xiaoming, ZHAO Youqun.Simulation analysis of car shelter air-conditioning[J].Journal of Harbin Institute of Technology, 2012, 44(3):92-95.(in Chinese) [7] 郑昊, 康宁, 蓝天.侧风环境下行驶的直背式轿车气动力计算[J].航空动力学报, 2007, 22(11):1858-1862. ZHENG Hao, KANG Ning, LAN Tian.Calculation of aerodynamic forces of a car with the effect of crosswind[J].Journal of Aerospace Power, 2007, 22(11):1858-1862.(in Chinese) [8] 索文超, 毕小平, 吕良栋.履带车辆动力舱空气流场的CFD模拟与试验研究[J].装甲兵工程学院学报, 2009, 23(2):29-32. SUO Wenchao, BI Xiaoping, LÜ Liangdong.Research on CFD simulation and test of airflow field in engine compartment of tracked vehicles[J].Journal of Academy of Armored Force Engineering, 2009, 23(2):29-32.(in Chinese) [9] 李振平, 凌云, 王剑, 等.坦克动力舱空气流场仿真研究[J].车辆与动力技术, 2008(3):24-26, 34. LI Zhenping, LING Yun, WANG Jian, et al.Study on simulation of the air flow in tank engine compartment[J].Vehicle and Power Technology, 2008(3):24-26, 34.(in Chinese) [10] Fluent Inc.Fluent user's guide[M].New Hampshire:Fluent Inc, 2006. [11] 张兆顺, 崔桂香.流体力学[M].北京:清华大学出版社, 2006. [12] 李娜, 吉洪湖. 涡扇发动机涡轮空气系统流动和传热性能的 CFD 分析[J].航空动力学报, 2008, 23(11):2075-2081. LI Na, JI Honghu. Numerical simulation of flow and heat transfer in turbine cooling system of a turbofan engine[J].Journal of Aerospace Power, 2008, 23(11):2075-2081.(in Chinese) [13] 毕小平, 刘西侠, 赵以贤, 等.坦克动力舱内三维空气流动数值模拟[J].内燃机工程, 2003(3):12-15. BI Xiaoping, LIU Xixia, ZHAO Yixian, et al.Numerical modeling of three dimension air flow in tank power train compartment[J].China Internal Combustion Engine Engineering, 2003(3):12-15.(in Chinese) [14] 谢永奇, 高红霞, 余建祖. 前飞状态下直升机动力舱通风冷却性能仿真[J].空气动力学学报, 2011, 29(5):651-657. XIE Yongqi, GAO Hongxia, YU Jianzu. Simulation on the ventilation cooling performance of the helicopter engine nacelle in forward flight[J].Acta Aerodynamica Sinica, 2011, 29(5):651-657. (in Chinese) [15] 吴德义, 王爱兰. 吸入式空冷汽轮发电机气体运动流场分析及应用[J].实验流体力学, 2010, 24(5):17-21. WU Deyi, WANG Ailan. Analysis and application of the flow field in ventilation ducts of intake air turb-type generator[J].Journal of Experiments in Fluid Mechanics, 2010, 24(5):17-21. (in Chinese)
点击查看大图
计量
- 文章访问数: 1223
- HTML浏览量: 1
- PDF量: 884
- 被引次数: 0