尾迹对低压涡轮边界层稳定性的影响

梁赟; 刘火星; 邹正平

doi:10.13224/j.cnki.jasp.2016.04.015

尾迹对低压涡轮边界层稳定性的影响

doi: 10.13224/j.cnki.jasp.2016.04.015

梁赟^1,2,
刘火星^1,2,
邹正平^1,2

1. 北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室, 北京 100191;
2. 先进航空发动机协同创新中心, 北京 100191

详细信息

作者简介:
梁赟(1986-),男,河北沧州人,博士生,主要从事叶轮机械气动热力学研究.

中图分类号: V211.7
计量
- 文章访问数: 1089
- HTML浏览量: 110
- PDF量: 672
- 被引次数: 0
出版历程
- 收稿日期: 2015-11-08
- 刊出日期: 2016-04-28

Influence of wakes on boundary layer stability in low-pressure turbines

1. National Key Laboratory of Science and Technology on Aero-Engine Aero-thermodynamics, School of Energy and Power Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China;
2. Collaborative Innovation Center for Advanced Aero-Engine, Beijing 100191

摘要

摘要: 在低压涡轮内部上游周期性扫过的尾迹是下游叶片排内最重要的非定常扰动源,会对边界层的失稳和转捩过程产生决定性的影响.在施加低压涡轮负荷分布的平板上,采用热线对雷诺数为130000工况下,有/无尾迹作用时分离剪切层中的速度波动进行了测量.通过对比两种工况下分离剪切层中的扰动发展,分析了尾迹对分离泡稳定性的影响.结果表明:在无尾迹来流工况下,扰动在分离泡前部的增长符合线性不稳定机制,扰动增长至饱和后非线性机制开始起作用.主导分离剪切层的失稳过程的为K-H(Kelvin-Helmholtz)无黏不稳定机制.尾迹与分离剪切层的相互作用产生的扰动的增长在分离泡前部同样满足线性不稳定机制.尾迹加速了分离剪切层的失稳转捩进程,从而抑制了分离.
- 低压涡轮 /
- 尾迹 /
- 边界层 /
- 分离泡 /
- 稳定性
Abstract: As the most important disturbance source, the wakes dominate the instability and transition process of boundary layer in low-pressure turbines. A detailed experimental study on the velocity fluctuation in a laminar separated shear layer on the flat plate of low-pressure turbine pressure distribution with the hot-wire probe at Reynolds number of 130000 were presented. The disturbance development under stable and instable incoming conditions was compared to analyze the influence of the wakes on the destabilization mechanism. Results show that the disturbance grows linearly in the former part of the separation bubble, and nonlinear interaction appears when the disturbance saturates, leading to vortex shedding at the maxima height of the bubble. Inviscid K-H(Kelvin-Helmholtz) mechanism dominates the instability process in the separation bubble. The occurrence of convective linear instability mechanisms was also revealed when amplifying the velocity fluctuations carried by wakes while propagating downstream. This accelerated the transition process and suppressed the separation bubble.
- low-pressure turbine /
- wake /
- boundary layer /
- separation bubble /
- stability

HTML

参考文献(24)

[1]	Chandrasekhar S.Hydrodynamic and hydromagnetic stability[M].Oxford:Oxford University Press,1961.
[2]	Yarusevych S,Kawall J G,Sullivan P E. Coherent structures in an airfoil boundary layer and wake at low Reynolds numbers[J].Physics of Fluids,2006,18(4):044101.1-044101.11.
[3]	Yarusevych S,Sullivan P E,Kawall J G.Separated-shear-layer development on an airfoil at low Reynolds numbers[J].AIAA Journal,2008,46(12):3060-3069.
[4]	Pauley L L,Moin P,Reynolds W C.The structure of two-dimensional separation[J].Journal of Fluid Mechanics,1990,220:397-411.
[5]	Haggmark C P,Bakchinov A A,Alfredsson P H.Experiments on a two-dimensional laminar separation bubble[J].Philosophical Transactions of the Royal Society:A Mathematical and Engineering Sciences,2000,358(1777):3193-3205.
[6]	Burgmann S,Schroder W.Investigation of the vortex induced unsteadiness of a separation bubble via time-resolved and scanning PIV measurements[J].Experiments in Fluids,2008,45:675-691.
[7]	Watmuff J H.Evolution of a wave packet into vortex loops in a laminar separation bubble[J].Journal of Fluid Mechanics,1999,397:119-169.
[8]	Roberts S K,Yaras M I.Boundary layer transition in separation-bubbles over rough surfaces[R].ASME Paper GT2004-53667,2004.
[9]	Roberts S K,Yaras M I.Effects of surface roughness geometry on separation bubble transition[R].ASME Paper GT2005-68664,2005.
[10]	Diwan S,Ramesh O N.On the origin of the inflectional instability of a laminar separation bubble[J].Journal of Fluid Mechanics,2009,629:263-298.
[11]	Rist U,Maucher U.Investigations of time-growing instabilities in laminar separation bubbles[J].European Journal of Mechanics:B/Fluids,2002,21(5):495-509.
[12]	Maucher U,Rist U,Kloker M,et al.DNS of laminar-turbulent transition in separation bubbles[C]//Proceedings of High Performance Computing in Science and Engineering.Heidelberg,Berlin:Springer-Verlag,2000:279-294.
[13]	Meyer R X.The effects of wakes on the transient pressure and velocity distributions in turbomachines[J].Journal of Basic Engineering,1958,80:1544-1552.
[14]	Stieger R D,Hodson H P.The unsteady development of a turbulent wake through a downstream low-pressure turbine blade passage[R].ASME Paper GT-2004-53061,2004.
[15]	Stieger R D,Hodson H P.Unsteady dissipation measurements on a flat plate subject to wake passing[R].Praha,Czech:The 5th European Conference on Turbomachinery Fluid Dynamics and Thermodynamics,2003.
[16]	Simoni D,Ubaldi M,Zunino P.Experimental investigation of the interaction between incoming wakes and instability mechanisms in a laminar separation bubble[J].Experimental Thermal and Fluid Science,2003,50:54-60.
[17]	LOU Weiliang,Hourmouziadis J.Separation bubbles under steady and periodic-unsteady main flow conditions[J].Journal of Turbomachinery,2003,122(4):634-643.
[18]	杨龙君.涡轮叶片边界层非定常流动实验模拟及测试技术研究[D].北京:北京航空航天大学,2012. YANG Longjun.Research on experimental simulation and testing technology for unsteady boundary layer flow on turbine blade[D].Beijing:Beijing University of Aeronautics and Astronautics,2012.(in Chinese)
[19]	Coull J D,Thomas R L,Hodson H P.Velocity distributions for low-pressure turbines[J].Journal of Turbomachinery,2010,132(4):041006.1-041006.13.
[20]	Pfeil H,Eifler J.Turbulenzverhaltnisse hinter rotierenden zylindergittern[J].Forschung im Ingeneiurswesen,1976,42:27-32.(in German)
[21]	Schulte V.Unsteady wake boundary layer interaction[D].Cambridge:Cambridge University,1995.
[22]	Ho C,Huerre P.Perturbed free shear layers[J].Annual Review of Fluid Mechanics,1984,16(1):365-422.
[23]	Horton H P.Laminar separation in two and three-dimensional incompressible flow[D].London:University of London,1968.
[24]	Stieger R D,Hodson H P.The transition mechanism of highly-loaded LP turbine blades[R].ASME Paper GT-2003-38304,2003.