熔盐泵盐析两相流冷态模型试验和数值研究

方向阳; 邵春雷; 杨勇

doi:10.13224/j.cnki.jasp.2018.06.014

熔盐泵盐析两相流冷态模型试验和数值研究

doi: 10.13224/j.cnki.jasp.2018.06.014

1.
南京工业大学机械与动力工程学院,南京 211816
2.
常州大学机械工程学院江苏省绿色过程装备重点实验室,江苏常州 213164

基金项目: 国家自然科学基金（51306087）；江苏省高等学校自然科学研究重大项目（17KJA480003）；江苏省“六大人才高峰项目”（GDZB-032）；江苏省绿色过程装备重点实验室开放课题基金（GPE201704）

计量
- 文章访问数: 725
- HTML浏览量: 60
- PDF量: 560
- 被引次数: 0
出版历程
- 收稿日期: 2016-12-04
- 刊出日期: 2018-06-28

Cold model experiments and numerical study on crystallization two-phase flow in molten salt pump

摘要

摘要: 为了揭示熔盐泵内盐析两相流动的规律,采用白金汉定理,建立了熔盐泵输送固液两相流的相似准则,根据所设计的熔盐泵模型试验方案,对熔盐泵内部流动进行了数值模拟,采用高速摄像技术捕捉了泵内的盐析两相流动,阐述了试验结果与模拟结果之间的差别。研究了颗粒直径和密度对熔盐泵外特性和内部流动的影响。结果表明：数值模拟结果和试验结果之间的误差小于10%。叶轮流道出口处颗粒的绝对速度从叶片的压力面到吸力面逐渐减小。分析得到了叶轮内固相和液相的速度三角形之间的关系,当颗粒的密度大于液相的密度时,颗粒绝对速度沿圆周方向的分量小于液相。进一步分析得到了叶轮出口处密度分别为2000、2250、2500、2750、3000kg/m3的颗粒的运动速度三角形之间的关系,颗粒密度越大,叶轮出口绝对速度沿圆周方向的分量越小,泵的扬程越小。
- 熔盐泵 /
- 盐析两相流 /
- 冷态模型试验 /
- 速度三角形 /
- 可视化试验
Abstract: In order to reveal the regularity of the crystallization two-phase flow in the molten salt pump, Buckingham theorem was adopted to establish the similarity criterion for the solid-liquid two-phase flow in molten salt pump. According to the designed molten salt pump model test schemes, the internal flow was numerically simulated. At the same time, the high speed photography technology was employed to capture the flow. The differences between experimental and numerical simulation results were elaborated. The effects of particle diameter and density on external performance and internal flow of molten salt pump were researched. The obtained results were shown as follows: the error between the numerical simulation results and the test results was less than 10%. The absolute velocity of particles at the impeller outlet decreased from the blade pressure surface to the suction surface. The relationship of the velocity triangles between the solid and liquid phases in the impeller was obtained. When the particle density was greater than the liquid density, the circumferential component of the particle absolute velocity was less than that of liquid phase. Furthermore, the relationship of the velocity triangles at the impeller outlet was obtained for particles with the density of 2000, 2250, 2500, 2750, 3000kg/m3. The larger particle density meant the smaller circumferential component of the absolute velocity and the lower pump head.
- molten salt pump /
- crystallization two-phase flow /
- cold model experiments /
- velocity triangle /
- visualization experiment

HTML

参考文献(18)

[1]	韩利峰,陈永忠,周大勇,等.HTS熔盐实验回路分布式控制系统设计［J］.核技术,2013,36(9):1-6.HAN Lifeng,CHEN Yongzhong,ZHOU Dayong,et al.Design of the distributed control system for HTS molten salt test loop［J］.Nuclear Techniques,2013,36(9):1-6.(in Chinese)
[2]	杨敏官,吴承福,高波,等.离心泵叶轮内盐析晶体颗粒分布特性试验［J］.江苏大学学报(自然科学版),2011,32(5):528-532.YANG Minguan,WU Cheugfu,GAO Bo,et al.Distribution feature experiment of salt-out crystal particles in a centrifugal pump impeller［J］.Journal of Jiangsu University (Natural Science Edition),2011,32(5):528-532.(in Chinese)
[3]	高波,杨敏官.旋流泵内颗粒分布及对盐析特性的影响［J］.工程热物理学报,2009,30(12):2031-2033.GAO Bo,YANG Minguan.Particle concentration distribution and its effect on salt-out features in a vortex pump［J］.Journal of Engineering Thermophysics,2009,30(12):2031-2033.(in Chinese)
[4]	邵春雷,顾伯勤,周剑锋,等.熔盐泵外特性及内部流动的试验及数值模拟［J］.航空动力学报,2016,31(8):1935-1942.SHAO Chunlei,GU Boqin,ZHOU Jianfeng,et al.Experiment and numerical simulation of external performances and internal flow of a molten salt pump［J］.Journal of Aerospace Power,2016,31(8):1935-1942.(in Chinese)
[5]	邵春雷,顾伯勤,黄星路,等.低比转速泵叶轮流道内部流动的PIV试验［J］.航空动力学报,2010,25(9):2091-2096.SHAO Chunlei,GU Boqin,HUANG Xinglu,et al.Experimental study on flow in the impeller of low specific speed pump using particle image velocimetry［J］.Journal of Aerospace Power,2010,25(9):2091-2096.(in Chinese)
[6]	LIU Dong,WANG Yayun,WANG Yingze,et al.Research of liquid-solid two phase flow in centrifugal pump with crystallization phenomenon［J］.International Journal of Fluid Machinery and Systems,2014,7(2):54-59.
[7]	刘栋,杨敏官,高波.离心泵叶轮内部伴有盐析流场的PIV试验［J］.农业机械学报,2008,39(11):55-58.LIU Dong,YANG Minguan,GAO Bo.PIV measurement of flow with salt-out in centrifugal pump［J］.Transactions of the Chinese Society for Agricultural Machinery,2008,39(11):55-58.(in Chinese)
[8]	杨敦敏.离心泵内两相流流动特性的图像测量［D］.西安:西安理工大学,2004.YANG Dunmin.Image measurement of two-phase flow characteristic in centrifugal pump impeller［D］.Xian:Xian University of Technology,2004.(in Chinese)
[9]	ZHU Bing,CHEN Hongxun,WEI Qun.Numerical and experimental investigation of cavitating characteristics in centrifugal pump with gap impeller［J］.International Journal of Turbo and Jet-Engines,2014,31(2):187-196.
[10]	马冬英,雷宗琪,梁国柱.基于相对流面理论的液体火箭发动机泵内部流动计算［J］.航空动力学报,2013,28(3):583-590.MA Dongying,LEI Zongqi,LIANG Guozhu.Calculation of internal flow in pump of liquid rocket engine based on theory of relative stream surface［J］.Journal of Aerospace Power,2013,28(3):583-590.(in Chinese)
[11]	张群峰,闫盼盼,单建平,等.航空发动机滑片泵数值模拟［J］.航空动力学报,2014,29(11):2537-2542.ZHANG Qunfeng,YAN Panpan,SHAN Jianping,et al.Numerical simulation on an aero-engine vane pump［J］.Journal of Aerospace Power,2014,29(11):2537-2542.(in Chinese)
[12]	杨敏官,邵腾,高波,等.熔盐泵分流式空间导叶内部流动及其非定常特性［J］.排灌机械工程学报,2015,33(4):306-310.YANG Minguan,SHAO Teng,GAO Bo,et al.Interior flow and unsteady performance of molten salt pump with splitter space guide vane［J］.Journal of Drainage and Irrigation Machinery Engineering,2015,33(4):306-310.(in Chinese)
[13]	李云校,康灿,朱宜超,等.蜗壳结构对立式高温熔盐泵性能的影响［J］.化工学报,2013,64(8):2853-2859.LI Yunxiao,KANG Can,ZHU Yichao,et al.Influence of volute structure on performance of vertically-installed high temperature molten salt pump［J］.Journal of Chemical Industry and Engineering,2013,64(8):2583-2859.(in Chinese)
[14]	SHAO Chunlei,ZHOU Jianfeng,CHENG Wenjie.Experimental and numerical study of external performance and internal flow of a molten salt pump that transports fluids with different viscosities［J］.International Journal of Heat and Mass Transfer,2015,89:627-640.
[15]	邵春雷,顾伯勤,周剑锋,等.离心泵内部流动高速摄像测量及误差分析［J］.农业工程学报,2015,31(24):52-58.SHAO Chunlei,GU Boqin,ZHOU Jianfeng,et al.Internal flow measurement in centrifugal pump by high speed photography and error analysis［J］.Transactions of the Chinese Society of Agricultural Engineering,2015,31(24):52-58.(in Chinese)
[16]	LISSETT B,MAURICIO G P.Experimental visualization of two-phase flow inside an electrical submersible pump stage［J］.Journal of Energy Resources Technology,2011,133(4):042901.1-042901.12.
[17]	ZHANG Yuliang,LI Yi,CUI Baoling,et al.Numerical simulation and analysis of solid-liquid two-phase flow in centrifugal pump［J］.Chinese Journal of Mechanical Engineering,2013,26(1):53-60.
[18]	刘栋.离心泵内部盐析流场的数值模拟及实验研究［D］.江苏镇江:江苏大学,2008.LIU Dong.Numerical simulation and PIV measurement of salt-out two-phase flow in centrifugal pump［D］.Zhen Jiang Jiangsu:Jiangsu University,2008.(in Chinese)