压气机叶顶区域周向模态特性的实验

姚丹; 田杰; 吴亚东; 欧阳华

doi:10.13224/j.cnki.jasp.2018.10.027

压气机叶顶区域周向模态特性的实验

doi: 10.13224/j.cnki.jasp.2018.10.027

1.
上海交通大学机械与动力工程学院,上海 200040；先进航空发动机协同创新中心,北京 100191
2.
海交通大学机械与动力工程学院,上海 200040；先进航空发动机协同创新中心,北京 100191

基金项目: 国家自然科学基金青年科学基金（11202132）

计量
- 文章访问数: 515
- HTML浏览量: 1
- PDF量: 435
- 被引次数: 0
出版历程
- 收稿日期: 2017-07-04
- 刊出日期: 2018-10-28

Experiment on circumferential mode characteristics ofaxial compressor tip flow

摘要

摘要: 针对压气机叶顶区域流动周向模态测试对传感器数量的要求及传感器数量受限时所产生的模态混叠现象,提出一种基于两套测点数组合来校准预测高阶周向模态的方法。结果表明：应用该方法,在实验测试中将可识别的模态阶数提升至原来的5倍。研究了轴流压气机叶顶区域压力脉动,捕捉到包括叶片通过频率(BPF)和旋转不稳定性频率(RIF)带凸起的叶顶区域流动模态特性。随着流量减少,频谱上对应的宽频带凸起结构向低频移动,主要周向模态阶数降低,但旋转角速度有所上升。压气机叶顶区域流动的时变特性分析表明,旋转不稳定性在时域上幅值波动较大,不稳定性明显。
- 轴流压气机 /
- 叶顶区域流动 /
- 旋转不稳定性 /
- 周向模态 /
- 时变特性
Abstract: Experiments measuring circumferential mode characteristics of compressors were made for the high demand for the number of sensors, and the aliasing of circumferential wave number when insufficient sensors were provided. A calibration and prediction of higher circumferential mode numbers was proposed using two sets of measuring points, unsteady pressure fluctuations near the tip region in an axial compressor were studied experimentally using this method and the upper limit of identifiable mode numbers was five times of the original method. Circumferential mode characteristics were captured both on blade passing frequency (BPF) and rotational instability frequency (RIF) under several flow conditions. The characteristic spectrum of rotating instability with broadband hump existed within a large range of flow conditions. Both frequency range and dominant circumferential wave number decreased with the flow rate, while at the same time circumferential angular velocity of rotating instability increased; strength of the pressure fluctuations varied significantly in time domain.
- axial compressor /
- tip flow /
- rotating instability /
- circumferential mode /
- time-resolved characteristics

HTML

参考文献(19)

[1]	乔渭阳.航空发动机气动声学［M］.北京:北京航空航天大学出版社,2010:4-7.
[2]	MATHIOUDAKIS K,BREUGELMANS F A E.Development of small rotating stall in a single stage axial compressor［R］.ASME Paper 85-GT-227,1985.
[3]	BAUMGARTNER M,KAMEIER F,HOURMOUZIADIS J.Non-engine order blade vibration in a high pressure compressor［R］.Melbourne,Australia:the 12th International Symposium on Airbreathing Engines,1995.
[4]	KAMEIER F,NEISE W.Rotating blade flow instability as a source of noise in axial turbomachines［J］.Journal of Sound and Vibration,1997,203(5):833-853.
[5]	MAILACH R,LEHMANN I,VOGELER K.Rotating instabilities in an axial compressor originating from the fluctuating blade tip vortex［J］.Journal of Turbomachinery,2001,123(3):453-463.
[6]	MRZ J,HAH C,NEISE W.An experimental and numerical investigation into the mechanisms of rotating instability［J］.Journal of Turbomachinery,2002,124(3):367-375.
[7]	VO H D.Role of tip clearance flow in rotating instabilities and nonsynchronous vibrations［J］.Journal of Propulsion and Power,2010,26(3):557-561.
[8]	PARDOWITZ B,TAPKEN U,ENGHARDT L.Time-resolved rotating instability waves in an annular cascade［R］.Colorado Springs,CO:the 18th AIAA and CEAS Aeroacoustics Conference,2012.
[9]	PARDOWITZ B,TAPKEN U,NEUHAUS L,et al.Experiments on an axial fan stage:time-resolved analysis of rotating instability modes［J］.Journal of Engineering for Gas Turbines and Power,2015,137(6):062505.1-062505.9.
[10]	NEUHAUS L,NEISE W.Active flow control to improve the aerodynamic and acoustic performance of axial turbomachines［R］.St.Louis,Missouri:the 1st Flow Control Conference,2002.
[11]	NEUHAUS L,SCHULZ J,NEISE,W,et al.Active control of the aerodynamic performance and tonal noise of axial turbomachines［J］.Proceedings of the Institution of Mechanical Engineers:Part A Journal of Power and Energy,2003,217(4):375-383.
[12]	HOLSTE F,NEISE W.Noise source identification in a prop fan model by means of acoustical near field measurements［J］.Journal of Sound and Vibration,1997,203(4):641-665.
[13]	LIU J M,HOLSTE F,NEISE W.On the azimuthal mode structure of rotating blade of instabilities in axial turbomachines［R］.State College,PA:the 2nd AIAA and CEAS Aeroacoustics Conference,1996.
[14]	应怀樵,董书伟,应明,等.信号处理中“奇妙”的混叠现象［R］.杭州:全国振动与噪声高技术及应用会议,2007.
[15]	姚丹,田杰,欧阳华,等.压气机旋转不稳定性的周向模态特性及其分解方法［J］.航空动力学报,2018,33(2):431-439.YAO Dan,TIAN Jie,OUYANG Hua,et al.Investigation into circumferential mode characteristic of rotating instability and its decomposition method in an axial compressor［J］.Journal of Aerospace Power,2018,33(2):431-439.(in Chinese)
[16]	WANG H,WU Y D,OUYANG H,et al.Circumferential propagating characteristics of tip leakage flow oscillation and its induced rotating pressure wave［J］.Proceedings of the Institution of Mechanical Engineers:Part A Journal of Power and Energy,2016,230(4):374-387.
[17]	WANG H,WU Y D,OUYANG H,et al.Investigations of rotating instability and fluctuating tip clearance flow in a low-speed axial compressor［J］.Proceedings of the Institution of Mechanical Engineers:Part G Journal of Aerospace Engineering,2016,230(6):981-994.
[18]	王昊,吴亚东,欧阳华,等.低速轴流压气机中气动旋转不稳定性和叶顶泄漏流脉动特性［J］.航空动力学报,2016,31(9):2239-2250.WANG Hao,WU Yadong,OUYANG Hua,et al.Aerodynamic rotating instability and fluctuated characteristics of tip clearance flow in low speed axial flow compressor［J］.Journal of Aerospace Power,2016,31(9):2239-2250.(in Chinese)
[19]	TYLER J M.Axial flow compressor noise studies［R］.Society of Automotive Engineers,SAE Technical Paper 620532,1962.