相变微胶囊悬浮液在树形微通道内的热力特性

马杰; 孙栗; 李松林; 彭浩; 王刚; 蔡晗

doi:10.13224/j.cnki.jasp.20200555

相变微胶囊悬浮液在树形微通道内的热力特性

doi: 10.13224/j.cnki.jasp.20200555

南京工业大学机械与动力工程学院，南京 211816

基金项目: 国家自然科学基金项目（51776095）；江苏省高等学校自然科学研究项目（20KJB470005）；江苏省博士后科研资助计划项目（2021K108B）

详细信息

作者简介:
马杰（1991-），男，讲师，博士，主要从事强化传热、节能环保技术与装备研究。

通讯作者:
彭浩（1981-），男，教授，博士，主要从事高效传热、工业节能与储能技术研究。E-mail：phsight1@hotmail.com

中图分类号: V231.1
计量
- 文章访问数: 399
- HTML浏览量: 226
- PDF量: 84
- 被引次数: 0
出版历程
- 收稿日期: 2020-12-25
- 刊出日期: 2021-12-28

Thermal performance of microencapsulated phase change material slurry in treelike microchannels

School of Mechanical and Power Engineering，Nanjing Tech University，Nanjing 211816，China

摘要

摘要: 以乙二醇水溶液为载冷基液制备了相变微胶囊悬浮液（MEPCMS），并测量了其物性参数，然后实验研究了MEPCMS在树形微通道内的热力特性，揭示了雷诺数、质量分数对MEPCMS热力性能的影响规律。结果表明：MEPCMS的比定压热容随着微胶囊质量分数与温度的增加而增大，黏度随着微胶囊质量分数的增加与温度的降低而增大；MEPCMS的表面传热系数随着雷诺数与质量分数的增大而增大，当雷诺数为118时，质量分数为1%、3%的MEPCMS的表面传热系数相对于载冷基液分别提高了3.92%和9.04%；MEPCMS的摩擦因子随雷诺数的增大与质量分数的减小而减小，但随着雷诺数的增加，MEPCMS的摩擦因子逐渐接近载冷基液。
- 低温 /
- 相变微胶囊 /
- 悬浮液 /
- 微通道 /
- 强化传热
Abstract: Micro-encapsulated phase change material slurry （MEPCMS） was prepared using glycol solution as cold-based solution，and its physical properties were measured.Then，the thermodynamic properties of MEPCMS in tree microchannels were experimentally studied to reveal the influence of Reynolds number and mass concentration on the thermodynamic properties of MEPCMS.The results showed that the specific heat capacity of MEPCMS increased with the increase of microcapsule mass concentration and temperature，and the viscosity of MEPCMS increased with the increase of microcapsule mass fraction and the decrease of temperature.The convective heat transfer coefficient of MEPCMS increased with Reynolds number and mass concentration.When Reynolds number was 118，the convective heat transfer coefficients of MEPCMS at 1% and 3% mass fraction increased by 3.92% and 9.04%，respectively，compared with the base solution.The friction factor of MEPCMS decreased with the increase of Reynolds number and the decrease of mass concentration，but the friction factor of MEPCMS gradually approached the base solution with the increase of Reynolds number.
- low temperature /
- microencapsulated phase change material /
- slurry /
- microchannel /
- transfer enhancement

HTML

参考文献(35)

[1]	饶宇,林贵平,罗燕,等.应用于强化传热的相变材料微胶囊的制备及特性[J].航空动力学报,2005,20（4）:651-655.
[2]	王亮,林贵平.相变材料微胶囊表面吸附纳米颗粒对传热过程的影响[J].航空动力学报,2011,26（9）:1947-1952.
[3]	王梦,吴宏,徐国强,等.微小通道流动换热特性分析及其结构优化[J].航空动力学报,2009,24（5）:994-999.
[4]	ZHANG Yinping,HU Xianxu,HAO Qing,et al.Convective heat transfer enhancement of laminar flow of latent functionally thermal fluid in a circular tube with constant heat flux: internal heat source model and its application[J].Science in China,2003,46（2）:131-140.
[5]	刘东,何蔚然,钟小龙,等.潜热型功能热流体在微小管道内的换热特性[J].化工进展,2016,35（10）：3042-3048.
[6]	LI Gang,HWANG Y,RADERNACHER R,et al.Review of cold storage materials for subzero applications[J].Energy,2013,51:1-17.
[7]	PENG Hao,ZHANG Dong,LING Xiang,et al.n-alkanes phase change materials and their microencapsulation for thermal energy storage:a critical review[J].Energy and Fuels,2018,32（7）:7262-7293.
[8]	D??ü?Cü D K,KIZIL ?,BI?ER A,et al.Microencapsulated n-alkane eutectics in polystyrene for solar thermal applications[J].Solar Energy,2018,160: 32-42.
[9]	SARI A,ALKAN C,BILGIN C.Micro/nano encapsulation of some paraffin eutectic mixtures with poly （methyl methacrylate） shell: preparation,characterization and latent heat thermal energy storage properties[J].Applied Energy,2014,136:217-227.
[10]	Al-SHANNAQ R,KURDI J,Al-MUHTASEB S,et al.Supercooling elimination of phase change materials （PCMs） microcapsules[J].Energy,2015,87:654-662.
[11]	WANG Tingyu,WANG Shuangfeng,LUO Ruilian,et al.Microencapsulation of phase change materials with binary cores and calcium carbonate shell for thermal energy storage[J].Applied Energy,2016,171:113-119.
[12]	ZHANG Yi,ZHENG Xianhua,WANG Haitao,et al.Encapsulated phase change materials stabilized by modified graphene oxide[J].Journal of Materials Chemistry A,2014,2（15）:5304-5314.
[13]	YU Fei,CHEN Zhonghua,ZENG Xingrong.Preparation,characterization,and thermal properties of microPCMs containing n-dodecanol by using different types of styrene-maleic anhydride as emulsifier[J].Colloid and Polymer Science,2009,287（5）:549-560.
[14]	DELGADO M,LAZAR A,PENALOSA C,et al.Experimental analysis of the influence of microcapsule mass fraction on the thermal and rheological behavior of a PCM slurry[J].Applied Thermal Engineering,2014,63（1）:11-22.
[15]	HO C J,SIAO C R,YAN W M.Thermal energy storage characteristics in an enclosure packed with MEPCM particles: an experimental and numerical study[J].International Journal of Heat and Mass Transfer,2014,73:88-96.
[16]	GIRO-PALOMA J,MARTINEZ M,CABEZA L F,et al.Types,methods,techniques,and applications for microencapsulated phase change materials （MPCM）:a review[J].Renewable and Sustainable Energy Reviews,2016,53:1059-1075.
[17]	HAN Shenjie,CHEN Yanping,Shaoyi LYU,et al.Effects of processing conditions on the properties of paraffin/melamine-urea-formaldehyde microcapsules prepared by in situ polymerization[J].Colloids and Surfaces A:Physicochemical and Engineering Aspects,2020,585:124046.1-124046.9.
[18]	ZHANG Huanzhi,WANG Xiaodong.Fabrication and performances of microencapsulated phase change materials based on n-octadecane core and resorcinol-modified melamine-formaldehyde shell[J].Colloids and Surfaces.A:Physicochemical and Engineering Aspects,2009,332（2/3）:129-138.
[19]	李杰,刘红研,汪树军,等.密胺树脂硫磺微胶囊的制备及应用[J].化工学报,2011,62（6）:1716-1722.
[20]	LI Min,CHEN Meirong,WU Zhishen.Enhancement in thermal property and mechanical property of phase change microcapsule with modified carbon nanotube[J].Applied energy,2014,127:166-171.
[21]	ZHANG Yan,JIANG Zhu,ZHANG Zhibing,et al.Polysaccharide assisted microencapsulation for volatile phase change materials with a fluorescent retention indicator[J].Chemical Engineering Journal,2019,359:1234-1243.
[22]	ZHANG Yan,BAIOCCO D,MUSTAPHA A N,et al.Hydrocolloids:nova materials assisting encapsulation of volatile phase change materials for cryogenic energy transport and storage[J].Chemical Engineering Journal,2020,382:123028.1-123028.16.
[23]	王燕,陈振乾.辛烷相变微胶囊微观熔化实验观测[J].太阳能学报,2014,35（8）:1499-1504.
[24]	ZHU Kongying,QI Hengzhi,WANG Shuang,et al.Preparation and characterization of melamine-formaldehyde resin micro- and nanocapsules filled with n-dodecane[J].Macromolecular Science Part B:Physics,2012,51（10）:1976-1990.
[25]	GHOGHAEI M S,MAHMOUDIAN A,MOHAMMADI O,et al.A review on the applications of micro-/nano-encapsulated phase change material slurry in heat transfer and thermal storage systems[J].Journal of Thermal Analysis and Calorimetry,2020,145（2）:245-268.
[26]	CHAI Lei,SHAUKAT R,WANG Liang,et al.A review on heat transfer and hydrodynamic characteristics of nano/microencapsulated phase change slurry （N/MPCS） in mini/microchannel heat sinks[J].Applied Thermal Engineering,2018,135:334-349.
[27]	RAO Yu,DAMMEL F,STEPHAN P,et al.Flow frictional characteristics of microencapsulated phase change material suspensions flowing through rectangular minichannels[J].Science in china,2006,49（4）:445-456.
[28]	RAO Yu,DAMMEL F,STEPHAN P,et al.Convective heat transfer characteristics of microencapsulated phase change material suspensions in minichannels[J].Heat and Mass Transfer,2007,44（2）:175-186.
[29]	饶宇,FRANK D,PETER S,等.相变材料微胶囊悬浮液在矩形小通道内层流流动传热的实验[J].航空动力学报,2006,21（6）:1012-1020.
[30]	DAMMEL F,STEPHAN P.Heat transfer to suspensions of microencapsulated phase change material flowing through minichannels[J].Journal of Heat Transfer,2012,134（2）:020907.1-020907.8.
[31]	WANG Yan,CHEN Zhenqian,LING Xiang.An experimental study of the latent functionally thermal fluid with micro-encapsulated phase change material particles flowing in microchannels[J].Applied Thermal Engineering,2016,105:209-216.
[32]	刘志敏,王燕.矩形微通道内相变微胶囊悬浮液换热特性[J].化工机械,2019,46（2）:137-141,172.
[33]	吴兴辉,杨震,陈颖,等.基于离散相模型的相变微胶囊流体传热特性数值模拟[J].化工学报,2020,71（4）:1491-1501.
[34]	CHEN Yongping,CHENG Ping.An experimental investigation on the thermal efficiency of fractal tree-like microchannel nets [J].International Communications in Heat and Mass Transfer,2005,32（4）:931-938.
[35]	XIE Gongnan,ZHANG Fengli,SUNDEN B,et al.Constructal design and thermal analysis of microchannel heat sinks with multistage bifurcations in single-phase liquid flow [J].Applied Thermal Engineering,2014,62（2）:791-802.