多股流S弯喷管红外辐射特性研究

徐建宇; 周莉; 是介; 孟钰博; 史经纬; 王占学

doi:10.13224/j.cnki.jasp.20230148

多股流S弯喷管红外辐射特性研究

doi: 10.13224/j.cnki.jasp.20230148

徐建宇¹,
周莉^{1, 2,*, ,},
是介¹,
孟钰博¹,
史经纬^{1, 2},
王占学^{1, 2}

1.
西北工业大学动力与能源学院，西安 710072
2.
先进航空发动机协同创新中心，北京 100191

基金项目: 国家自然科学基金（52376032，52076180）；陕西省杰出青年科学基金（2021JC-10）；国家科技重大专项（J2019-Ⅱ-0015-0036）；航空发动机及燃气轮机基础科学中心项目（P2022-B-Ⅰ-002-001，P2022-B-Ⅱ-010-001）；中央高校基本科研业务费专项资金(501XTCX2023146001)

详细信息

作者简介:
徐建宇（1998-），男，博士生，主要从事高超声速飞行器红外辐射研究

通讯作者:
周莉（1978-），女，教授、博士生导师，博士，研究领域为排气系统设计及流动控制技术。E-mail：zhouli@nwpu.edu.cn

中图分类号: V231
计量
- 文章访问数: 617
- HTML浏览量: 218
- PDF量: 74
- 被引次数: 0
出版历程
- 收稿日期: 2023-03-13
- 网络出版日期: 2024-09-16

Investigation on infrared radiation characteristics of multi-stream serpentine nozzle

XU Jianyu¹,
ZHOU Li^{1, 2,*
, ,},
SHI Jie¹,
MENG Yubo¹,
SHI Jingwei^{1, 2},
WANG Zhanxue^{1, 2}

1.
School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China
2.
Collaborative Innovation Center for Advanced Aero-Engine，Beijing 100191，China

摘要

摘要:
针对自适应发动机用多S弯喷管，通过数值模拟的方法研究了在设计工况及非设计工况下红外辐射强度的空间分布特征，分析了红外辐射特征产生机理及影响因素。结果表明：在设计工况下，由于主流形状弯曲造成内流出口上壁面产生热斑，使得垂直探测面负探测角度壁面红外辐射强度占总辐射最高达54%；在其他探测角度下燃气红外辐射强度为主要辐射来源，喷管内部燃气辐射强度显著高于喷流辐射强度。在非设计工况下，壁面红外辐射强度基本不变；落压比增加导致喷管内部燃气压力与出口波系发生变化，造成喷管内部燃气红外辐射强度增强，喷流红外辐射强度减弱。燃气红外辐射强度受到内部燃气和喷流的共同影响。
- 自适应发动机 /
- 多股流S弯喷管 /
- 离散传递法 /
- 红外辐射特征 /
- 落压比
Abstract:
A numerical simulation was carried out to investigate the spatial distribution characteristics of infrared radiation intensity of a multi-stream serpentine nozzle for an adaptive engine under both design and off-design conditions. The underlying mechanisms and influencing factors of the IR radiation characteristics were comprehensively analyzed. The results revealed that under design conditions, the curvature of the mainstream shape caused a hot spot to form on the upper wall of the nozzle outlet, resulting in the wall infrared radiation intensity accounting for up to 54% of the total radiation at a negative detection angle on the vertical plane. The gas infrared radiation intensity was identified as the main source of radiation at other angles, and the gas radiation intensity within the nozzle was significantly higher than that of the plume radiation intensity. Under off-design conditions, the wall infrared radiation intensity remained relatively constant. An increase in the pressure ratio led to changes in the internal gas pressure and exit shock waves shape of the nozzle, resulting in an enhanced gas infrared radiation intensity within the nozzle, and a weakened plume infrared radiation intensity. The gas infrared radiation intensity was jointly affected by internal gas and plume radiations.
- adaptive engine /
- multi-stream serpentine nozzle /
- discrete transfer method /
- infrared radiation characteristics /
- pressure ratio

HTML

图 1 多股流S弯喷管模型

Figure 1. Model of multi-stream serpentine nozzle

下载: 全尺寸图片幻灯片

图 2 计算网格及边界条件

Figure 2. Numerical grid and boundary conditions

下载: 全尺寸图片幻灯片

图 3 网格无相关性验证

Figure 3. Result of grid independent

下载: 全尺寸图片幻灯片

图 4 窄谱带模型与逐线计算法对比

Figure 4. Comparison between SNB and LBL

下载: 全尺寸图片幻灯片

图 5 固体壁面m的辐射亮度示意图

Figure 5. Illustration of luminance of solid wall m

下载: 全尺寸图片幻灯片

图 6 探测点及探测面布置示意图

Figure 6. Schematic diagram of probe points and planes

下载: 全尺寸图片幻灯片

图 7 多股流S弯喷管红外辐射强度分布

Figure 7. Infrared radiation intensity of TISN on two probe plane

下载: 全尺寸图片幻灯片

图 8 喷管对称面压力与温度分布

Figure 8. Static pressure and temperature distribution of nozzle section

下载: 全尺寸图片幻灯片

图 9 喷管主流壁面温度分布

Figure 9. Wall temperature distribution of nozzle mainstream

下载: 全尺寸图片幻灯片

图 10 垂直探测面可见区域温度分布随探测角度变化

Figure 10. Temperature distribution of visible nozzle wall on vertical plane with different angles

下载: 全尺寸图片幻灯片

图 11 垂直探测面正探测角度测点可视喷管壁面区域

Figure 11. Visible area of nozzle wall on vertical plane with positive angle

下载: 全尺寸图片幻灯片

图 12 垂直探测面燃气吸收距离随探测角度变化

Figure 12. Gas absorption distance distribution with different angles on vertical plane

下载: 全尺寸图片幻灯片

图 13 垂直探测面上核心流投影面积随探测角度变化

Figure 13. Core plume area with different angles on vertical plane

下载: 全尺寸图片幻灯片

图 14 喷管内部高温气流可探测区域示意图

Figure 14. Schematic diagram of internal high temperature gas visible area of nozzle

下载: 全尺寸图片幻灯片

图 15 水平探测面可见区域温度分布随探测角变化

Figure 15. Temperature distribution of visible nozzle wall on horizontal plane with different angles

下载: 全尺寸图片幻灯片

图 16 水平探测面燃气吸收距离随探测角度变化

Figure 16. Gas absorption distance distribution with different angles on horizontal plane

下载: 全尺寸图片幻灯片

图 17 垂直探测面不同NPR红外辐射特性分布

Figure 17. Infrared radiation intensity on vertical plane with different NPRs

下载: 全尺寸图片幻灯片

图 18 不同NPR水平探测面红外辐射强度分布

Figure 18. Infrared radiation intensity on horizontal plane with different NPRs

下载: 全尺寸图片幻灯片

图 19 喷管沿程截面气流温度分布

Figure 19. Gas temperature distribution along the nozzle section

下载: 全尺寸图片幻灯片

图 20 不同NPR下出口燃气温度分布

Figure 20. Section diagram of gas temperature distribution with different NPRs

下载: 全尺寸图片幻灯片

图 21 不同NPR下CO₂摩尔分数分布

Figure 21. CO₂ mole fraction distribution with different NPRs

下载: 全尺寸图片幻灯片

图 22 不同NPR下喷管出口密度梯度分布

Figure 22. Density gradient distribution of nozzle outlet with different NPRs

下载: 全尺寸图片幻灯片

图 23 不同NPR下α=20°喷管内部压力分布

Figure 23. Pressure distribution of nozzle of α=20° with different NPRs

下载: 全尺寸图片幻灯片

参考文献(36)

[1]	GE’s XA100 adaptive cycle engine: dramatically transforming tomorrow’s missions[EB/OL]. [2015-09-04]. https://www.geaviation.com/military/engines/ge-adaptive-cycle-engine.
[2]	ZHENG Junchao,TANG Hailong,CHEN Min,et al. Equilibrium running principle analysis on an adaptive cycle engine[J]. Applied Thermal Engineering,2018,132: 393-409. doi: 10.1016/j.applthermaleng.2017.12.102
[3]	ZHANG Jiyuan,TANG Hailong,CHEN Min. Robust design of an adaptive cycle engine performance under component performance uncertainty[J]. Aerospace Science and Technology,2021,113: 106704. doi: 10.1016/j.ast.2021.106704
[4]	LYU Ya,TANG Hailong,CHEN Min. A study on combined variable geometries regulation of adaptive cycle engine during throttling[J]. Applied Sciences,2016,6(12): 374. doi: 10.3390/app6120374
[5]	孙明霞,梁春华. 美国自适应发动机研究的进展与启示[J]. 航空发动机,2017,43(1): 95-102. SUN Mingxia,LIU Chunhua. Progress and revelation of us adaptive cycle engine development[J]. Aeroengine,2017,43(1): 95-102. (in Chinese SUN Mingxia, LIU Chunhua. Progress and revelation of us adaptive cycle engine development[J]. Aeroengine, 2017, 43(1): 95-102. (in Chinese)
[6]	ZHOU Zeyang,HUANG Jun. Mixed design of radar/infrared stealth for advanced fighter intake and exhaust system[J]. Aerospace Science and Technology,2021,110: 106490. doi: 10.1016/j.ast.2021.106490
[7]	CHENG Wen,WANG Zhanxue,ZHOU Li,et al. Influences of shield ratio on the infrared signature of serpentine nozzle[J]. Aerospace Science and Technology,2017,71: 299-311. doi: 10.1016/j.ast.2017.09.001
[8]	高翔,施永强,杨青真,等. 介质涂覆位置对双S弯排气系统电磁散射特性影响研究[J]. 物理学报,2015,64(2): 24103. GAO Xiang,SHI Yongqiang,YANG Qingzhen,et al. Electromagnetic scattering characteristics of double S-shap e exhaust nozzle with different coating medium parts[J]. Acta Physica Sinica,2015,64(2): 24103. (in Chinese doi: 10.7498/aps.64.024103 GAO Xiang, SHI Yongqiang, YANG Qingzhen, et al. Electromagnetic scattering characteristics of double S-shap e exhaust nozzle with different coating medium parts[J]. Acta Physica Sinica, 2015, 64(2): 24103. (in Chinese) doi: 10.7498/aps.64.024103
[9]	罗明东,吉洪湖,黄伟,等. 二元喷管热喷流的红外光谱辐射特性实验[J]. 推进技术,2007,28(2): 152-156. LUO Mingdong,JI Honghu,HUANG Wei,et al. Experiment on spectral infrared radiation characteristics of exhaust jet from 2D nozzle of turbofan engine[J]. Journal of Propulsion Technology,2007,28(2): 152-156. (in Chinese LUO Mingdong, JI Honghu, HUANG Wei, et al. Experiment on spectral infrared radiation characteristics of exhaust jet from 2D nozzle of turbofan engine[J]. Journal of Propulsion Technology, 2007, 28(2): 152-156. (in Chinese)
[10]	MAGSTADT A,BERRY M,SHEA P,et al. Aeroacoustic experiments on supersonic multi-aperture nozzles[R]. AIAA-2015-1512,2015.
[11]	RUSCHER C J,MAGSTADT A S,BERRY M G,et al. Investigation of a supersonic jet from a three-stream engine nozzle[J]. AIAA Journal,2018,56(4): 1554-1568. doi: 10.2514/1.J055910
[12]	STACK C M,GAITONDE D V,AGOSTINI L,et al. Numerical investigation of a supersonic multistream jet with an aft-deck[R]. AIAA-2016-2058,2016.
[13]	TINNEY C E. Wall pressure unsteadiness on the aft deck of a planar multi-stream supersonic nozzle[R]. AIAA2017-0525,2017.
[14]	HROMISIN S M,MCLAUGHLIN D K,MORRIS P J,et al. Effects of nozzle configuration and bypass ratio on the aeroacoustics of dual stream supersonic jets[R]. AIAA2019-2766,2019.
[15]	周慧晨,谭慧俊,李湘萍. 复杂变截面进气道的一种设计方法[J]. 航空动力学报,2009,24(6): 1357-1363. ZHOU Huichen,TAN Huijun,LI Xiangping. Unique design method of subsonic inlet with complex cross-sectional shape[J]. Journal of Aerospace Power,2009,24(6): 1357-1363. (in Chinese ZHOU Huichen, TAN Huijun, LI Xiangping. Unique design method of subsonic inlet with complex cross-sectional shape[J]. Journal of Aerospace Power, 2009, 24(6): 1357-1363. (in Chinese)
[16]	李岳锋,杨青真,孙志强. 超椭圆 S 形进气道的设计及气动性能研究[J]. 计算机仿真,2011,28(3): 82-85,96. LI Yuefeng,YANG Qingzhen,SUN Zhiqiang. Designof super-elliptic S-shaped inlet and analysis of aerodynamic performance[J]. Computer Simulation,2011,28(3): 82-85,96. (in Chinese LI Yuefeng, YANG Qingzhen, SUN Zhiqiang. Designof super-elliptic S-shaped inlet and analysis of aerodynamic performance[J]. Computer Simulation, 2011, 28(3): 82-85, 96. (in Chinese)
[17]	SUN Xiaolin,WANG Zhanxue,ZHOU Li,et al. Experimental and computational investigation of double serpentine nozzle[J]. Proceedings of the Institution of Mechanical Engineers: Part G Journal of Aerospace Engineering,2015,229(11): 2035-2050. doi: 10.1177/0954410014564402
[18]	SUN Xiaolin,WANG Zhanxue,ZHOU Li,et al. Influences of design parameters on a double serpentine convergent nozzle[J]. Journal of Engineering for Gas Turbines and Power,2016,138(7): 072301. doi: 10.1115/1.4032338
[19]	SHAN Yong,ZHOU Xiaoming,TAN Xiaoming,et al. Parametric design method and performance analysis of double S-shaped nozzles[J]. International Journal of Aerospace Engineering,2019,2019: 4694837.
[20]	孙鹏,周莉,王占学,等. 双涵道S弯喷管内/外流场的温度分布研究[J]. 西北工业大学学报,2021,39(6): 1331-1339. SUN Peng,ZHOU Li,WANG Zhanxue,et al. Temperature distributions of internal flow and external jet fields of double serpentine convergent nozzle for turbofan[J]. Journal of Northwestern Polytechnical University,2021,39(6): 1331-1339. (in Chinese doi: 10.1051/jnwpu/20213961331 SUN Peng, ZHOU Li, WANG Zhanxue, et al. Temperature distributions of internal flow and external jet fields of double serpentine convergent nozzle for turbofan[J]. Journal of Northwestern Polytechnical University, 2021, 39(6): 1331-1339. (in Chinese) doi: 10.1051/jnwpu/20213961331
[21]	罗明东,吉洪湖,黄伟,等. 涡扇发动机二元喷管的红外光谱辐射特性实验[J]. 推进技术,2012,28(4): 394-398. LUO Mingdong,JI Honghu,HUANG Wei,et al. Experiment on spectral infrared radiant characteristics of two-dimensional nozzles of turbofan engine[J]. Journal of Propulsion Technology,2012,28(4): 394-398. (in Chinese LUO Mingdong, JI Honghu, HUANG Wei, et al. Experiment on spectral infrared radiant characteristics of two-dimensional nozzles of turbofan engine[J]. Journal of Propulsion Technology, 2012, 28(4): 394-398. (in Chinese)
[22]	程稳,周莉,王占学,等. 几何参数对S弯喷管红外辐射特性的影响[J]. 推进技术,2018,39(9): 1974-1985. CHENG Wen,ZHOU Li,WANG Zhanxue,et al. Effects of geometric parameters on infrared signature of serpentine nozzle[J]. Journal of Propulsion Technology,2018,39(9): 1974-1985. (in Chinese CHENG Wen, ZHOU Li, WANG Zhanxue, et al. Effects of geometric parameters on infrared signature of serpentine nozzle[J]. Journal of Propulsion Technology, 2018, 39(9): 1974-1985. (in Chinese)
[23]	杨承宇,张靖周,单勇. 单边膨胀喷管红外辐射特性的数值模拟[J]. 航空学报,2010,31(10): 1919-1926. YANG Chengyu,ZHANG Jingzhou,SHAN Yong. Numerical simulation on infrared radiation characteristics of single expansion ramp nozzles[J]. Acta Aeronautica et Astronautica Sinica,2010,31(10): 1919-1926. (in Chinese YANG Chengyu, ZHANG Jingzhou, SHAN Yong. Numerical simulation on infrared radiation characteristics of single expansion ramp nozzles[J]. Acta Aeronautica et Astronautica Sinica, 2010, 31(10): 1919-1926. (in Chinese)
[24]	是介,周莉,史经纬,等. 三轴承矢量喷管红外辐射特性[J]. 航空动力学报,2022,37(6): 1195-1205. SHI Jie,ZHOU Li,SHI Jingwei,et al. Infrared radiation signature of three bearing swivel nozzle[J]. Journal of Aerospace Power,2022,37(6): 1195-1205. (in Chinese SHI Jie, ZHOU Li, SHI Jingwei, et al. Infrared radiation signature of three bearing swivel nozzle[J]. Journal of Aerospace Power, 2022, 37(6): 1195-1205. (in Chinese)
[25]	孙啸林,王占学,周莉,等. 基于多参数耦合的S弯隐身喷管设计方法研究[J]. 工程热物理学报,2015,36(11): 2371-2375. SUN Xiaolin,WANG Zhanxue,ZHOU Li,et al. The design method of serpentine stealth nozzle based on coupled parameters[J]. Journal of Engineering Thermophysics,2015,36(11): 2371-2375. (in Chinese SUN Xiaolin, WANG Zhanxue, ZHOU Li, et al. The design method of serpentine stealth nozzle based on coupled parameters[J]. Journal of Engineering Thermophysics, 2015, 36(11): 2371-2375. (in Chinese)
[26]	LEE C,BOEDICKER C. Subsonic diffuser design and performance for advanced fighter aircraft[R]. AIAA1985-3073,1985.
[27]	孙啸林. 低可探测S弯喷管设计及性能评估方法研究[D]. 西安: 西北工业大学,2018. SUN Xiaolin. Study on design and performance evaluation method of low detectable S-bend nozzle[D]. Xi’an: Northwestern Polytechnical University,2018. (in Chinese SUN Xiaolin. Study on design and performance evaluation method of low detectable S-bend nozzle[D]. Xi’an: Northwestern Polytechnical University, 2018. (in Chinese)
[28]	程稳. S弯喷管红外辐射特性预测及优化设计方法[D]. 西安: 西北工业大学,2019. CHENG Wen. Prediction and optimization design method of infrared radiation characteristics of S-bend nozzle[D]. Xi’an: Northwestern Polytechnical University,2019. (in Chinese CHENG Wen. Prediction and optimization design method of infrared radiation characteristics of S-bend nozzle[D]. Xi’an: Northwestern Polytechnical University, 2019. (in Chinese)
[29]	CHENG Wen,WANG Zhanxue,ZHOU Li,et al. Infrared signature of serpentine nozzle with engine swirl[J]. Aerospace Science and Technology,2019,86: 794-804. doi: 10.1016/j.ast.2019.01.057
[30]	CROWE D S,MARTIN C L. Effect of geometry on exit temperature from serpentine exhaust nozzles[R]. AIAA2015-1670,2015.
[31]	CROWE D S,JR MARTIN C L. Hot streak characterization in serpentine exhaust nozzles[R]. AIAA-2016-4502,2016.
[32]	GOODY R M,YUNG Y L. Absorption by atmospheric gases[M]//Atmospheric Radiation. Oxford,UK: Oxford University Press,1989.
[33]	MALKMUS W. Random Lorentz band model with exponential-tailed S^–1 line-intensity distribution function[J]. Journal of the Optical Society of America,1967,57(3): 323. doi: 10.1364/JOSA.57.000323
[34]	YOUNG S J. Nonisothermal band model theory[J]. Journal of Quantitative Spectroscopy and Radiative Transfer,1977,18(1): 1-28. doi: 10.1016/0022-4073(77)90125-X
[35]	RIVIÈRE P,SOUFIANI A. Updated band model parameters for H₂O,CO₂,CH₄ and CO radiation at high temperature[J]. International Journal of Heat and Mass Transfer,2012,55(13/14): 3349-3358.
[36]	SOUFIANI A,TAINE J. High temperature gas radiative property parameters of statistical narrow-band model for H₂O,CO₂ and CO,and correlated-K model for H₂O and CO₂[J]. International Journal of Heat and Mass Transfer,1997,40(4): 987-991. doi: 10.1016/0017-9310(96)00129-9