掺氢预混燃烧室动态压力特性试验与数值模拟

梁红侠; 黄文朴; 巨翃宇; 索建秦; 高家春

doi:10.13224/j.cnki.jasp.20250095

掺氢预混燃烧室动态压力特性试验与数值模拟

doi: 10.13224/j.cnki.jasp.20250095

梁红侠^{1, 2, 3,},
黄文朴¹,
巨翃宇¹,
索建秦¹,
高家春⁴

1.
西北工业大学动力与能源学院，西安 710129
2.
中国航发四川燃气涡轮研究院高空模拟技术重点实验室，四川绵阳 621000
3.
西北工业大学陕西省航空动力系统热科学重点实验室，西安 710129
4.
中国航发燃气轮机有限公司，沈阳 110015

基金项目: 中国航空发动机集团产学研合作项目（HFZL2021CXY002-2）；国家自然科学基金重点项目（12232002）

详细信息

作者简介:
梁红侠（1979-），女，副教授，博士，主要从事燃气轮机燃烧技术研究。E-mail：hx_liang@nwpu.edu.cn

中图分类号: V231.2
计量
- 文章访问数: 725
- HTML浏览量: 344
- PDF量: 58
- 被引次数: 0
出版历程
- 收稿日期: 2025-02-26
- 网络出版日期: 2025-07-23

Experimental and numerical study on dynamic pressure characteristics in hydrogen blending premixed combustor

1.
School of Power and Energy，Northwestern Polytechnical University，Xi’an 710129，China
2.
Science and Technology Altitude Simulation Laboratory，Sichuan Gas Turbine Research Institute，Aero Engine Corporation of China，Mianyang Sichuan 621000，China
3.
Shaanxi Key Laboratory of Thermal Sciences in Aero-engine System，Northwestern Polytechnical University，Xi’an 710129，China
4.
Gas Turbine Company，Limited，Aero Engine Corporation of China，Shenyang 110015，China

摘要

摘要:
氢燃料因其具有零碳可再生的优势目前是燃气轮机的重要研究方向，但由于氢能燃烧化学反应速率快、燃烧速度高，容易引发热声振荡现象。为探究天然气掺氢预混燃烧室声学特性，针对不同掺氢比与湍流脉动速度下燃烧室内的动态压力进行了试验测量与数值计算。研究表明：试验工况下，在掺氢比例从0%增至30%的过程中，随着氢气混合比例的提升，燃烧室内的动态压力主频保持在70 Hz至76 Hz的范围内，而当掺氢比例达到40%时，动态压力脉动主频从75.36 Hz跃升到197 Hz，出现模态转换现象。随着湍流脉动速度的提高，动态压力振荡频率逐渐提高。数值计算工况下，随着掺氢比例的增加，燃烧室内的高频动态压力基本呈现逐渐提高的趋势，OH基分布基本呈现向外扩散的趋势，不同掺氢比例下燃烧室内涡团均由旋转模式向涡脱落模式转化，纯氢燃烧中的离散涡团破碎显著高于其他掺氢比例方案，该趋势与OH基分布随掺氢比例的变化规律一致。
- 燃气轮机 /
- 掺氢燃料 /
- 预混燃烧室 /
- 燃烧不稳定 /
- 动态压力试验
Abstract:
Hydrogen fuel is currently an important research direction for gas turbines due to its advantages of zero carbon emissions and renewability. However, due to the fast chemical reaction rate and high combustion velocity of hydrogen, thermoacoustic oscillations can be easily triggered. To investigate the acoustic characteristics of the natural gas hydrogen premixed combustor, experimental measurements and numerical calculations were conducted on the dynamic pressure inside the combustor under different hydrogen blending ratios and turbulent pulsation velocities. The results showed that under the test conditions, during the process of increasing the hydrogen blending ratio from 0% to 30%, as the hydrogen blending ratio increased, the main frequency of dynamic pressure in the combustor remained within the range of 70 Hz to 76 Hz. However, when the hydrogen blending ratio reached 40%, the main frequency of dynamic pressure pulsation jumped from 75.36 Hz to 197 Hz, indicating a mode transition phenomenon. With the increase of turbulent pulsation velocity, the frequency of dynamic pressure oscillation gradually increased. Under numerical calculation conditions, with the increase of hydrogen blending ratio, the high-frequency dynamic pressure inside the combustor showed a gradually increasing trend, and the distribution of OH radicals showed a trend of outward diffusion. Under different hydrogen blending ratios, the vortex clusters in the combustor transformed from rotation mode to vortex shedding mode. The discrete vortex cluster fragmentation in pure hydrogen combustion was significantly higher than that in other hydrogen blending ratio schemes, which was consistent with the variation of OH radical distribution with hydrogen blending ratio.
- gas turbine /
- hydrogen blending fuel /
- premixed combustor /
- combustion instability /
- dynamic pressure experiment

HTML

图 1 掺氢预混燃烧室结构

Figure 1. Hydrogen-enriched fuel premixed combustor structure

下载: 全尺寸图片幻灯片

图 2 试验系统示意图

Figure 2. Schematic of combustor test rig system

下载: 全尺寸图片幻灯片

图 3 掺氢预混燃烧室试验平台

Figure 3. Picture of combustor test rig system

下载: 全尺寸图片幻灯片

图 4 动态压力测点位置（单位：mm）

Figure 4. Location of dynamic pressure measurement points（unit：mm）

下载: 全尺寸图片幻灯片

图 5 不同掺氢比例测点1处动态压力脉动频谱图

Figure 5. Dynamic pressure pulsation spectrum at point 1 under different hydrogen blending ratios

下载: 全尺寸图片幻灯片

图 6 掺氢比例为50%的动态压力测量结果

Figure 6. Realtime dynamic pressure data under 50% hydrogen blending ratio

下载: 全尺寸图片幻灯片

图 7 掺氢比例为50%时的各测点动态压力频谱图

Figure 7. Dynamic pressure pulsation spectrum at different measurement points under 50% hydrogen blending ratio

下载: 全尺寸图片幻灯片

图 8 不同试验工况下燃烧室OH基场分布

Figure 8. Distribution of OH radical field in the combustion chamber under different experimental conditions

下载: 全尺寸图片幻灯片

图 9 不同湍流脉动速度各测点动态压力频谱图

Figure 9. Dynamic pressure pulsation spectrum of dynamic pressure at different measurement points under different turbulent fluctuation velocities

下载: 全尺寸图片幻灯片

图 10 燃烧室物理模型

Figure 10. Physical model of combustor

下载: 全尺寸图片幻灯片

图 11 燃烧室网格划分截面图

Figure 11. Combustor mesh cross-section diagram

下载: 全尺寸图片幻灯片

图 12 不同网格数的轴向速度计算结果

Figure 12. Axial velocity calculation results with different grid numbers

下载: 全尺寸图片幻灯片

图 13 数值计算验证

Figure 13. Numerical calculation validation

下载: 全尺寸图片幻灯片

图 14 不同掺氢比例下动态压力脉动频谱图

Figure 14. Dynamic pressure pulsation spectrum under different hydrogen blending ratios

下载: 全尺寸图片幻灯片

图 15 不同掺氢比例下时域声压图

Figure 15. Time-domain sound pressure diagrams under different hydrogen blending ratios

下载: 全尺寸图片幻灯片

图 16 不同数值计算工况下燃烧室OH基场分布

Figure 16. Distribution of OH radical field in the combustion chamber under different numerical conditions

下载: 全尺寸图片幻灯片

图 17 不同掺氢比例下轴向速度与涡结构云图

Figure 17. Axial velocity and vortex structure contour plots under different hydrogen blending ratios

下载: 全尺寸图片幻灯片

表 1 试验工况表

Table 1. Test condition table

序号	掺氢比例/%	湍流脉动速度/（m/s）	质量流量/（g/s）
序号	掺氢比例/%	湍流脉动速度/（m/s）	天然气	空气
1	0	0.12	0.70	19.82
2	10	0.12	0.67	19.82
3	20	0.12	0.63	19.82
4	30	0.12	0.59	19.82
5	40	0.12	0.55	19.82
6	50	0.12	0.49	19.82
7	30	0.10	0.47	15.82
8	30	0.14	0.71	23.79

下载: 导出CSV

表 2 数值仿真工况表

Table 2. Numerical simulation operating condition table

序号	掺氢比例/%	质量流量/（g/s）
序号	掺氢比例/%	天然气	氢气流量
1	0	9.18	0
2	30	8.2	0.41
3	50	7.17	0.84
4	70	5.55	1.51
5	85	3.55	2.35
6	100	0	3.83

下载: 导出CSV

参考文献(25)

[1]	田书耘, 朱志劼, 蒋俊, 等. 氢燃料燃气轮机研发现状和最新技术进展[J]. 能源研究与管理, 2021(4): 10-17, 41. TIAN Shuyun, ZHU Zhijie, JIANG Jun, et al. Research and ddevelopment status and the latest technological progress of hydrogen fuel gas turbine research[J]. Energy Research and Management, 2021(4): 10-17, 41. (in Chinese TIAN Shuyun, ZHU Zhijie, JIANG Jun, et al. Research and ddevelopment status and the latest technological progress of hydrogen fuel gas turbine research[J]. Energy Research and Management, 2021(4): 10-17, 41. (in Chinese)
[2]	İLBAŞ M, YıLMAZ İ. Experimental analysis of the effects of hydrogen addition on methane combustion[J]. International Journal of Energy Research, 2012, 36(5): 643-647. doi: 10.1002/er.1822
[3]	向巧, 胡晓煜, 王曼, 等. 关于氢能航空动力发展的认识与思考[J]. 航空发动机, 2024, 50(1): 1-9. XIANG Qiao, HU Xiaoyu, WANG Man, et al. Observations on the development of hydrogen-powered aircraft propulsion system[J]. Aeroengine, 2024, 50(1): 1-9. (in Chinese XIANG Qiao, HU Xiaoyu, WANG Man, et al. Observations on the development of hydrogen-powered aircraft propulsion system[J]. Aeroengine, 2024, 50(1): 1-9. (in Chinese)
[4]	魏胜. 氢气和稀释气体对甲烷/空气预混火焰稳定燃烧特性的影响规律研究[D]. 重庆: 重庆大学, 2014. WEI Sheng. Study on the influence of hydrogen and diluent gas on the stable combustion characteristics of methane/air premixed flame[D]. Chongqing: Chongqing University, 2014. (in Chinese WEI Sheng. Study on the influence of hydrogen and diluent gas on the stable combustion characteristics of methane/air premixed flame[D]. Chongqing: Chongqing University, 2014. (in Chinese)
[5]	李敬法, 苏越, 张衡, 等. 掺氢天然气管道输送研究进展[J]. 天然气工业, 2021, 41(4): 137-152. LI Jingfa, SU Yue, ZHANG Heng, et al. Research progresses on pipeline transportation of hydrogen-blended natural gas[J]. Natural Gas Industry, 2021, 41(4): 137-152. (in Chinese doi: 10.3787/j.issn.1000-0976.2021.04.015 LI Jingfa, SU Yue, ZHANG Heng, et al. Research progresses on pipeline transportation of hydrogen-blended natural gas[J]. Natural Gas Industry, 2021, 41(4): 137-152. (in Chinese) doi: 10.3787/j.issn.1000-0976.2021.04.015
[6]	SHIH H Y, LIU Chirong. A computational study on the combustion of hydrogen/methane blended fuels for a micro gas turbines[J]. International Journal of Hydrogen Energy, 2014, 39(27): 15103-15115. doi: 10.1016/j.ijhydene.2014.07.046
[7]	PATEL V, SHAH R. Effect of hydrogen enrichment on combustion characteristics of methane swirling and non-swirling inverse diffusion flame[J]. International Journal of Hydrogen Energy, 2019, 44(52): 28316-28329. doi: 10.1016/j.ijhydene.2019.09.076
[8]	WU Long, KOBAYASHI N, LI Zhanyong, et al. Emission and heat transfer characteristics of methane–hydrogen hybrid fuel laminar diffusion flame[J]. International Journal of Hydrogen Energy, 2015, 40(30): 9579-9589. doi: 10.1016/j.ijhydene.2015.05.096
[9]	ZHENG Kai, YU Minggao, LIANG Yunpei, et al. Large eddy simulation of premixed hydrogen/methane/air flame propagation in a closed duct[J]. International Journal of Hydrogen Energy, 2018, 43(7): 3871-3884. doi: 10.1016/j.ijhydene.2018.01.045
[10]	LI Yanchao, BI Mingshu, LI Bei, et al. Effects of hydrogen and initial pressure on flame characteristics and explosion pressure of methane/hydrogen fuels[J]. Fuel, 2018, 233: 269-282. doi: 10.1016/j.fuel.2018.06.042
[11]	BOURAS F, EL HADI ATTIA M, KHALDI F, et al. Control of methane flame properties by hydrogen fuel addition: Application to power plant combustion chamber[J]. International Journal of Hydrogen Energy, 2017, 42(13): 8932-8939. doi: 10.1016/j.ijhydene.2016.11.146
[12]	JONES D R, AL-MASRY W A, DUNNILL C. Hydrogen-enriched natural gas as a domestic fuel: an analysis based on flash-back and blow-off limits for domestic natural gas appliances within the UK[J]. Sustainable Energy & Fuels, 2018, 2(4): 710-723.
[13]	李祥晟, 郭菡, 郁鸿飞, 等. 掺氢对燃气轮机燃烧室燃烧和排放性能的影响研究[J]. 西安交通大学学报, 2022, 56(6): 9-16. LI Xiangsheng, GUO Han, YU Hongfei, et al. Study on combustion and emission performance of hydrogen fuel gas turbine combustor[J]. Journal of Xi’an Jiaotong University, 2022, 56(6): 9-16. (in Chinese doi: 10.7652/xjtuxb202206002 LI Xiangsheng, GUO Han, YU Hongfei, et al. Study on combustion and emission performance of hydrogen fuel gas turbine combustor[J]. Journal of Xi’an Jiaotong University, 2022, 56(6): 9-16. (in Chinese) doi: 10.7652/xjtuxb202206002
[14]	秦琨, 王威, 李妍萍, 等. 掺氢比对低排放燃烧室性能影响研究[J]. 热能动力工程, 2024, 39(3): 47-56. QIN Kun, WANG Wei, LI Yanping, et al. Study on the influence of hydrogen blending ratio on low emission combustor performance[J]. Journal of Engineering for Thermal Energy and Power, 2024, 39(3): 47-56. (in Chinese QIN Kun, WANG Wei, LI Yanping, et al. Study on the influence of hydrogen blending ratio on low emission combustor performance[J]. Journal of Engineering for Thermal Energy and Power, 2024, 39(3): 47-56. (in Chinese)
[15]	王鑫慈. 掺氢燃料贫预混旋流燃烧特性研究[D]. 沈阳: 沈阳航空航天大学, 2023. WANG Xinci. Study on lean premixed swirl combustion characteristics of hydrogen-doped fuel[D]. Shenyang: Shenyang Aerospace University, 2023. (in Chinese WANG Xinci. Study on lean premixed swirl combustion characteristics of hydrogen-doped fuel[D]. Shenyang: Shenyang Aerospace University, 2023. (in Chinese)
[16]	马勤勇, 钱白云, 董利江, 等. 掺氢比例对氢混天然气燃气轮机运行特性影响的研究[J]. 热能动力工程, 2022, 37(9): 41-49. MA Qinyong, QIAN Baiyun, DONG Lijiang, et al. Research on the influence of hydrogen blending ratio on the operation characteristics of hydrogen blended fuel gas turbine[J]. Journal of Engineering for Thermal Energy and Power, 2022, 37(9): 41-49. (in Chinese MA Qinyong, QIAN Baiyun, DONG Lijiang, et al. Research on the influence of hydrogen blending ratio on the operation characteristics of hydrogen blended fuel gas turbine[J]. Journal of Engineering for Thermal Energy and Power, 2022, 37(9): 41-49. (in Chinese)
[17]	贾亮, 李惠林, 何锋, 等. 当量比对掺氢天然气预混燃烧特性的影响[J]. 热能动力工程, 2015, 30(5): 725-729, 823. JIA Liang, LI Huilin, HE Feng, et al. Influence of the equivalent ratio on the premixed combustion characteristics of natural gas mixed and diluted with hydrogen[J]. Journal of Engineering for Thermal Energy and Power, 2015, 30(5): 725-729, 823. (in Chinese JIA Liang, LI Huilin, HE Feng, et al. Influence of the equivalent ratio on the premixed combustion characteristics of natural gas mixed and diluted with hydrogen[J]. Journal of Engineering for Thermal Energy and Power, 2015, 30(5): 725-729, 823. (in Chinese)
[18]	崔耀欣, 刘晓佩, 陈明敏. F级重型燃气轮机燃烧器天然气掺氢全压试验研究[J]. 燃气轮机技术, 2021, 34(2): 38-42. CUI Yaoxin, LIU Xiaopei, CHEN Mingmin. Experimental study of natural gas mixed with hydrogen under full pressure of F-class heavy duty gas turbine burner[J]. Gas Turbine Technology, 2021, 34(2): 38-42. (in Chinese CUI Yaoxin, LIU Xiaopei, CHEN Mingmin. Experimental study of natural gas mixed with hydrogen under full pressure of F-class heavy duty gas turbine burner[J]. Gas Turbine Technology, 2021, 34(2): 38-42. (in Chinese)
[19]	赵昊, 楼国锋, 刘少鹏, 等. 掺氢对天然气燃烧室燃烧及排放特性影响数值模拟[J]. 科学技术与工程, 2024, 24(16): 6821-6827. ZHAO Hao, LOU Guofeng, LIU Shaopeng, et al. Numerical simulation of the effect of hydrogen mixing on combustion and emission characteristics of the natural gas combustor[J]. Science Technology and Engineering, 2024, 24(16): 6821-6827. (in Chinese doi: 10.12404/j.issn.1671-1815.2303567 ZHAO Hao, LOU Guofeng, LIU Shaopeng, et al. Numerical simulation of the effect of hydrogen mixing on combustion and emission characteristics of the natural gas combustor[J]. Science Technology and Engineering, 2024, 24(16): 6821-6827. (in Chinese) doi: 10.12404/j.issn.1671-1815.2303567
[20]	高贤智, 何沛, 冯晓星, 等. 单扇区、扇形、全环燃烧室热声不稳定性试验和模拟研究[J]. 航空动力学报, 2021, 36(8): 1605-1613. GAO Xianzhi, HE Pei, FENG Xiaoxing, et al. Experimental and numerical investigation of thermo-acoustic instability in single-sector, sector and full annular combustors[J]. Journal of Aerospace Power, 2021, 36(8): 1605-1613. (in Chinese GAO Xianzhi, HE Pei, FENG Xiaoxing, et al. Experimental and numerical investigation of thermo-acoustic instability in single-sector, sector and full annular combustors[J]. Journal of Aerospace Power, 2021, 36(8): 1605-1613. (in Chinese)
[21]	马静, 郭志辉. 贫燃预混旋流火焰的模态转换燃烧不稳定特性分析[J]. 推进技术, 2020, 41(5): 1072-1081. MA Jing, GUO Zhihui. Analysis of combustion instability characteristics of mode switching on lean-premixed swirling flame[J]. Journal of Propulsion Technology, 2020, 41(5): 1072-1081. (in Chinese MA Jing, GUO Zhihui. Analysis of combustion instability characteristics of mode switching on lean-premixed swirling flame[J]. Journal of Propulsion Technology, 2020, 41(5): 1072-1081. (in Chinese)
[22]	隋永枫, 张宇明, 臧鹏, 等. 轴向分级燃烧室热声稳定性的试验研究[J]. 工程热物理学报, 2024, 45(6): 1625-1633. SUI Yongfeng, ZHANG Yuming, ZANG Peng, et al. Experimental study on thermoacoustic instability of an axially staged combustor[J]. Journal of Engineering Thermophysics, 2024, 45(6): 1625-1633. (in Chinese SUI Yongfeng, ZHANG Yuming, ZANG Peng, et al. Experimental study on thermoacoustic instability of an axially staged combustor[J]. Journal of Engineering Thermophysics, 2024, 45(6): 1625-1633. (in Chinese)
[23]	巨翃宇, 梁红侠, 索建秦, 等. 某航改燃机氢燃料燃烧室污染排放特性研究[J]. 推进技术, 2024, 45(3): 2209039. JU Hongyu, LIANG Hongxia, SUO Jianqin, et al. Study on pollution emission characteristics of hydrogen fuel combustion chamber of an aviation to gas turbine[J]. Journal of Propulsion Technology, 2024, 45(3): 2209039. (in Chinese JU Hongyu, LIANG Hongxia, SUO Jianqin, et al. Study on pollution emission characteristics of hydrogen fuel combustion chamber of an aviation to gas turbine[J]. Journal of Propulsion Technology, 2024, 45（3）: 2209039. (in Chinese)
[24]	吴颖, 阴松凯, 田金光. 半无限长管在高温脉动压力测试中的应用研究[J]. 科技创新与应用, 2016, 6(26): 35. WU Ying, YIN Songkai, TIAN Jinguang. Study on application of semi-infinite tube in high temperature pulsating pressure test[J]. Technology Innovation and Application, 2016, 6(26): 35. (in Chinese WU Ying, YIN Songkai, TIAN Jinguang. Study on application of semi-infinite tube in high temperature pulsating pressure test[J]. Technology Innovation and Application, 2016, 6(26): 35. (in Chinese)
[25]	赵雪林, 张力, 杨仲卿, 等. 低浓度甲烷均相燃烧动力学反应机理简化与分析[J]. 工程热物理学报, 2015, 36(4): 901-906. ZHAO Xuelin, ZHANG Li, YANG Zhongqing, et al. Reduction and analysis of kinetics model for low concentration methane homogeneous combustion[J]. Journal of Engineering Thermophysics, 2015, 36(4): 901-906. (in Chinese ZHAO Xuelin, ZHANG Li, YANG Zhongqing, et al. Reduction and analysis of kinetics model for low concentration methane homogeneous combustion[J]. Journal of Engineering Thermophysics, 2015, 36(4): 901-906. (in Chinese)