导弹从发射箱热发射过程的数值分析

梁晓扬; 苏逸飞; 乐贵高

doi:10.13224/j.cnki.jasp.20210308

导弹从发射箱热发射过程的数值分析

doi: 10.13224/j.cnki.jasp.20210308

南京理工大学机械工程学院，南京 210094

详细信息

作者简介:
梁晓扬（1989-），男，博士生，研究领域导弹发射过程热力环境。E⁃mail：Mr_Liangxiao@163.com

通讯作者:
乐贵高（1964-），男，教授，博士，主要从事火箭导弹发射系统流体力学数值模拟。E⁃mail：leguigao@njust.edu.cn

中图分类号: V231.1
计量
- 文章访问数: 126
- HTML浏览量: 72
- PDF量: 69
- 被引次数: 0
出版历程
- 收稿日期: 2021-06-17

Numerical analysis of hot launch of missile from a launch canister

School of Mechanical Engineering，Nanjing University of Science and Technology，Nanjing 210094，China

摘要

摘要:
采用三维可压缩雷诺平均Navier⁃Stokes方程和k⁃ε湍流模型，研究了导弹出箱过程中，弹体姿态偏转后弹底周围环境及发射箱内的流场特性。首先，以超声速欠膨胀射流撞击平板实验为算例，对数值方法的有效性进行验证。其次，分别对导弹在约束期和半约束期箱内流动特性展开研究。研究表明：喷管尾流在发射箱内会形成强烈的引射效应。同时，在弹底会出现明显的回流区域，使导弹出箱时受到额外的阻力。考虑偏转后，发射装置受到的冲击载荷增大2倍以上，发射箱壁面受到的压力增加40%。而且，在半约束期，箱内的流场分布不再对称，会使得导弹受到额外的不平衡力矩。
- 射流冲击 /
- 非同时离轨 /
- 发射箱 /
- 引射效应 /
- 二次流
Abstract:
Based on the three⁃dimensional compressible Reynolds⁃averaged Navier⁃Stokes equation and the k⁃ε turbulence model，the environment around the bottom of the missile and the flow field characteristics in the launch canister after deflection of the missile attitude were investigated.Firstly，the effectiveness of the numerical method was verified by the experiment of supersonic jet impinging on a flat plate.Secondly，the flow characteristics of the launch canister in the constrained and semi⁃confined periods were investigated respectively.The results showed that significant entrainment effect of the exhaust gas can be found in the launch canister.Meanwhile，a backflow area near the bottom of the missile can be observed，which may cause additional drag force on the missile during the launching process.After considering the deflection，the impact load on the launcher was increased by more than two times and the pressure on the launch box wall was increased by 40%.Moreover，the flow field distribution inside the box was no longer symmetrical during the semi⁃confinement period，making the missile subject to additional unbalanced moments.
- jet impingement /
- non simultaneous derailment /
- launch canister /
- ejection effect /
- secondary flow
注释:

1) 张雪

HTML

图 1 发射箱模型图

Figure 1. Schematic diagram of the launch canister

下载: 全尺寸图片幻灯片

图 2 导弹出箱过程（单位：mm）

Figure 2. Missile out of the box process （unit:mm）

下载: 全尺寸图片幻灯片

图 3 计算域模型

Figure 3. Computational domain

下载: 全尺寸图片幻灯片

图 4 计算网格

Figure 4. Computational grid

下载: 全尺寸图片幻灯片

图 5 Grid a~Grid d沿喷嘴轴线上的压力分布

Figure 5. Pressure distributions along the nozzle axis of the Grid a~Grid d

下载: 全尺寸图片幻灯片

图 6 实验结果与本文计算结果流场对比图

Figure 6. Flow field comparison between experimental results and calculation results

下载: 全尺寸图片幻灯片

图 7 数值结果与实验结果比较

Figure 7. Numerical results compared with experimental results

下载: 全尺寸图片幻灯片

图 8 在对称平面和Z=2.0D,Z=6.3D处马赫数分布

Figure 8. Mach number distribution in the symmetry plane and Z=2.0D,Z=6.3D

下载: 全尺寸图片幻灯片

图 9 全约束期对称平面上速度矢量

Figure 9. Velocity vector in the symmetry plane during full constraint period

下载: 全尺寸图片幻灯片

图 10 $X =$ 0.6D和 $X =$ 2.0D处的速度矢量

Figure 10. Velocity vector at $X =$ 0.6D and $X =$ 2.0D

下载: 全尺寸图片幻灯片

图 11 对称平面和 $X =$ 2.0D， $X =$ 6.3D横截面上的马赫数分布

Figure 11. Mach number distribution in the symmetry plane and $X =$ 2.0D, $X =$ 6.3D cross section

下载: 全尺寸图片幻灯片

图 12 发射箱上表面温度分布

Figure 12. Temperature distribution on the upper surface of the launch canister

下载: 全尺寸图片幻灯片

图 13 对称平面上速度矢量图

Figure 13. Velocity vector in the symmetry plane

下载: 全尺寸图片幻灯片

下载: 全尺寸图片幻灯片

下载: 全尺寸图片幻灯片

下载: 全尺寸图片幻灯片

下载: 全尺寸图片幻灯片

参考文献(18)

[1]	BERTIN J,BERTIN R,YUNG A,et al.The launch⁃tube flow⁃field for a vertical launching system[R].AIAA 88⁃0332,1988.
[2]	SAMIMY M,TURNER W,ADDY A.Backflow induced unsteady aerodynamic forces during tube launch[R].AIAA 87⁃0464,1987.
[3]	BOUSLOG S A,BERTIN J J,WINGERT W B.Flowfield produced by rocket exhaust impingement of a multitube launcher[J].Journal of Spacecraft and Rockets,1984,21（4）:323⁃329.
[4]	BERLIN J J,BATSON J L.Experimentally determined rocket⁃exhaust flowfield in a constrictivetube launcher[J].Journal of Spacecraft and Rockets,1975,12（12）:711⁃717.
[5]	张程,李新田,廖选平,等.固体火箭发动机后效推力对导弹底阻影响的数值仿真[J].航空动力学报,2017,32（6）:1530⁃1536. ZHANG Cheng,LI Xintian,LIAO Xuanping,et al.Numerical simulation of influences of solid rocket motor post⁃thrust on missile base drag[J].Journal of Aerospace Power,2017,32（6）:1530⁃1536.（in Chinese）
[6]	LAMONT P J,HUNT B L.The impingement of underexpanded,axisymmetric jets on perpendicular and inclined flat plates[J].Journal of Fluid Mechanics,1980,100（3）:471⁃511.
[7]	NAKAI Y,FUJIMATSU N,FUJII K.Flow classification of the under⁃expanded super sonic jet impinging on a flat plate[R].AIAA 2003⁃3467,2003.
[8]	NAKAI Y,FUJIMATSU N,FUJII K.Experimental study of underexpanded supersonic jet impingement on an inclined flat plate[J].AIAA Journal,2006,44（11）:2691⁃2699.
[9]	BERLIN J J,BATSON J L.Experimentally determined rocket⁃exhaust flowfield in a constrictivetube launcher[J].Journal of Spacecraft and Rockets,1975,12（12）:711⁃717.
[10]	SINHA P K,CHAKRABORTY D.Numerical study of hot launch of missile inside a tube[J].Journal of Aerospace Engineering,2014,228（14）:2604⁃2611.
[11]	KORST H H,BERTIN J J.Analysis of secondary flows for tube⁃launched rocket configurations[J].Journal of Spacecraft and Rockets,1983,20（1）:35⁃42.
[12]	VATSA V N,WEDAN B W.Development of a multigrid code for 3⁃D Navier⁃Stokes equations and its application to a grid⁃refinement study[J].Computers & Fluids,1990,18（4）:391⁃403.
[13]	BUSH M B,TANNER R I.Numerical solution of viscous flows using integral equation methods[J].International Journal for Numerical Methods in Fluids,1983,3（1）:71⁃92.
[14]	SHIH T H,LIOU W W,SHABBIR A,et al.A new k⁃ϵ eddy viscosity model for high reynolds number turbulent flows[J] Computers & Fluids 1995,24（3）:227‑238.
[15]	EL⁃AMIN,M F,SUN S,HEIDEMANN W,et al.Analysis of a turbulent buoyant confined jet modeled using realizable k‑ɛ model[J].Heat and Mass Transfer,2010,46（8）:943⁃960.
[16]	CHIMA R,LIOU M S.Comparison of the AUSM+ and H⁃CUSP schemes for turbomachinery applications[R].AIAA 2003⁃4120,2003.
[17]	VENKATAKRISHNAN V.Convergence to steady state solutions of the Euler equations on unstructured grids with limiters[J].Journal of Computational Physics,1995,118（1）:120‑130.
[18]	ALVI F,IYER K.Mean and unsteady flowfield properties of supersonic impinging jets with lift plates[R].AIAA 99⁃1829,1999.